Kent · TR19 inspections and grease testing
TR19 inspections in Ripple
For TR19 inspection in Ripple, one call is all it takes: survey, fixed quote, work and sign-off. CHAS and SafeContractor accredited, ISO 9001 and fully insured.
- Systems cleaned on a calendar with no measurements
- Heavy grease suspected in the plenum or ducts
- Pre-clean surveys before a first TR19 clean
What happens on the day
Everything the job needs comes with us, including protection sheets, the right tools and access kit. You only need to give us clear access and switch off what needs to be off. On site, the work takes around an hour or two per canopy and duct system. Photos of the system and how to reach it help us plan a visit to Ripple.
- First we book a time that won’t disrupt cooking.
- We look over the canopy, plenum, ducts, fan and discharge.
- Grease thickness is measured at set points by WFTT or DTT.
- Photos are taken at each point, and access gaps noted.
- We send a report setting out the readings, pictures and next steps.
Getting ready for the visit
- Allow time for equipment near the work to be turned off and cool down
- Arrange a key holder or contact on site
- Have your last certificate or report to hand
Getting a quote
Getting a quote does not take long. Call or email with a few details and you’ll normally have a fixed price within one working day. Where a survey is needed, we arrange a time that suits the site.
Advice
How we handle TR19 inspection in Ripple
Under TR19® Grease, the mean grease thickness should stay at or below 200 microns between cleans, while a reading of 500 microns or more anywhere calls for immediate spot cleaning. Grease testing shows which side of those lines you are on. We’re often asked to deal with uncertainty over how often to clean and surveys needed before quoting a full clean, across pre-clean surveys, wet film thickness tests and insurer audits.
Rural kitchens often have long, low duct runs through a roof space or along an outside wall, and those horizontal sections are where grease settles. We agree access and timings in advance.
Think of the report as the system’s health record: a dated account with photos of everything we did. For TR19® Grease cleans, the certificate comes through the BESCA Vent Hygiene Elite portal, ready for your insurer.
- Location
- Ripple (CT14)
- Region
- Kent
- Reporting
- Certificate and photo report
- Price
- A fixed quote up front
- When we work
- Evenings, overnight and weekends; 24/7 emergencies
- Phone
- 0345 646 2711
- Updated
- 30 October 2026
Common questions in Ripple
Is TR19 inspection any different in a coastal place like Ripple?
Yes, to a degree: at about 3 miles from the coast, Ripple gets salt-laden air that corrodes metal faster. Corroded fixings and housings are noted on the report so they can be dealt with.
Do you work at weekends in Ripple?
Yes, out-of-hours work is a big part of what we do. It means the site in Ripple keeps running as normal. Your opening times are the first thing we ask for.
What is post-clean verification?
Verification means repeat readings and photos once the clean is done. Any areas that weren’t cleaned properly are flagged.
Do you have a 24/7 line?
Yes. If something urgent happens, like a fan failing or damage after a fire, call our 24/7 line, and we will advise on what to do next.
How much time does an inspection need?
An inspection takes a morning or less for one kitchen, more where there are several systems. Sites with several canopies take longer, and you can phone us on 0345 646 2711 or email us to book it in.
Which sectors do you work in?
All kinds of commercial and public premises: from restaurants, pubs and hotels to schools, hospitals, care homes, offices, shops and food production sites. Work is timed around how each site runs.
Do you offer maintenance contracts?
Yes. We run scheduled maintenance contracts, set at the interval the system needs. Each report recommends when the next visit should be.
What happens to the waste?
It’s contained and taken away. We collect grease, debris and waste water as we go, so it doesn’t spread.
Landlords, agents and facilities managers
Landlords, managing agents and facilities managers book us, not only the businesses that use the systems. Where a system serves more than one tenant, such as a shared riser, it helps to agree who arranges the work, and we are happy to quote for all of it.
Facilities teams in offices, schools and healthcare sites book us too in Ripple and across Kent. Work can be phased by floor, building or site to keep disruption down.
Fixed quotes for TR19 inspection in Ripple
Sites vary more than people expect. The main factors:
- One-off work versus a regular cycle
- Any permits to work or inductions
- The scale of the work
- How easy every part is to reach
What you pay reflects the actual work. That’s why every job is surveyed first, and the price is agreed before any work starts.
Helping us quote
When you call or email, these details help:
- Close-ups of filters, grilles, hatches or access panels
- Photos showing the whole system and its surroundings
- Where the site is and what kind of site it is
- The times we could work without disrupting the site
For TR19 inspection in Ripple, call 0345 646 2711, or send details by email. Tell us what kind of premises it is and when it’s open, and send pictures or your last report if you can. A fixed quote usually follows within one working day.
Staff cleaning versus specialist work
A few tasks are always specialist work: entering ducts, working on fans, testing dampers and taking grease readings need training, the right equipment and safe access. Leave those to us.
Away from the kitchen, the in-house job is mainly checking: keeping grilles clear, noting unusual noise or smells and logging filter changes. Cleaning inside ducts and units is specialist work.
Towns and villages near Ripple
Other services in Ripple
Between visits
A little care between visits keeps the system in better shape. Our advice:
- Keep the route to access panels clear
- Keep grease filters clean and fitted properly
- Flag oily drips near the extract
- Send TR19 audit reports to your insurer on request
Each report suggests the next clean and the next test, based on the readings and how the kitchen is used.
Revisit the cleaning interval whenever the menu or hours change. A quick grease test answers the question.
What TR19 inspection looks like in Ripple
At about 3 miles from the coast, Ripple is close enough for sea air to matter. Corrosion on the fan housing and cowl is worth a look at every clean, alongside the grease. The FSA’s data shows about 5 bars, pubs and nightclubs registered within about 1.5 miles of central Ripple. Where they serve hot food, their kitchen extracts need cleaning to TR19® like any restaurant’s. In Ripple, food businesses are inspected by environmental health officers from Dover council. A greasy canopy or dripping filters are the sort of thing an inspection can pick up. A TR19® certificate and photo report after each clean gives you a record to show an inspector.
Volunteers running a hall kitchen near Church of St Mary the Virgin, or anywhere in Ripple, may not know when the extract was last cleaned, and a grease test settles it. Older buildings often hide long, awkward duct runs, and if you run a kitchen at a historic venue in the area (Walmer Castle is about 1.9 miles east), access may need planning.
Ripple is about 2 miles south-west of Deal, in Kent. Anywhere in CT14, we cover TR19 inspection for commercial sites. Our area takes in 922 places across Kent, large and small. Our Maidstone page covers sites nearby (36 miles or so).
Here we cover the CT14 postcode area for TR19 inspection. Whether your site is on Mongeham Road, Sunnyside Close and Sutton Lane or a nearby road, we can help. Other places close to Ripple include Great Mongeham (1 mile north), Mill Hill (1 mile north-east), Northbourne (2 miles north-west), Sholden Meadows (2 miles north) and Sholden (2 miles north-east). Larger places within reach include Canterbury (13 miles north-west), Margate (12 miles north), Dover (5 miles south-west), Folkestone (12 miles south-west), Ramsgate (10 miles north) and Broadstairs (12 miles north).
Local landmarks in Ripple
We work in commercial kitchens and buildings around Goodwin Academy and the streets around them. For rail, the closest station is Walmer station, roughly 1.1 miles east of the centre. Well-known places in the area include Royal Victoria Hospital (5.5 miles south-west) and Kent Museum of the Moving Image (2.4 miles north-east).
Do you need TR19 inspection in Ripple?
Not every section of a kitchen extract is easy to get to, so those sections can be skipped time and again. An inspection of a system in Ripple shows where access panels are missing, so the gaps can be closed.
If you notice any of these, it’s worth a diagnosis:
- Checking the result of a recent clean
- Sections of duct that cannot be reached
- Pre-clean surveys before a first TR19 clean
- Extracts that may be over the 200 micron mean
If you look after a school kitchen, at a school such as St Mary's Catholic Primary School or anywhere near Ripple, the holidays are the usual time for a TR19® clean.
Questions to ask before booking
- What paperwork you get at the end
- How they set the interval to the next visit
- Whether a survey comes first
- Whether the whole system is included, or only the parts that are easy to reach
Why it’s worth doing now in Ripple
If a kitchen in Ripple has been cleaned on the same calendar for years, there’s no way to know if that interval is right without measuring. Measured readings let a competent person set the interval. Rural sites can’t always move to another kitchen or room when something fails.
Every site is different, so we price each one individually. Size, access, the condition of the system and when we can work all play a part.
Why Ripple businesses choose us
- Out-of-hours work and a 24/7 emergency line
- Accredited under CHAS and SafeContractor, with ISO 9001
- One contact for all your sites in London and the South East
- A BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease
Take a look at our cost guide or our accreditations and certificates.