East Sussex · Extract fan repair and replacement
Pell Green extract fan repair
Extract fan repair and replacement for commercial sites in Pell Green and across East Sussex. CHAS, SafeContractor and ISO 9001, and fully insured.
- A belt-driven fan that squeals
- A fan worn beyond sensible repair
- A whining or grinding extract motor
How the job changes from site to site
Belt-driven fans
A squeal when the fan starts is a classic belt symptom. We check the belt condition, tension and alignment and renew them where needed.
Impellers and housings
A damaged or corroded impeller can’t simply be cleaned. It may be replaced on its own, or with the whole fan.
Extract fan repair in Pell Green, done properly
Grease and fans don’t mix. A coated impeller spins unevenly and the vibration wears out bearings and fixings. That’s why we check the grease whenever we work on a fan, and a full TR19® clean can be booked alongside. The work covers belts and pulleys, fan housings and fan motors, and common reasons people get in touch are an old fan that needs replacing and a fan shaking on its mountings.
In a small place like Pell Green, fans are often on an outside wall or roof, open to wind and rain. That, with the grease, is hard on motors and bearings.
It’s worth checking any contractor’s accreditations. Ours are BESCA Vent Hygiene Elite membership, cleaning to BESA TR19® Grease, plus CHAS, SafeContractor and ISO 9001, and we’re fully insured.
- Place
- Pell Green (TN5)
- Wider area
- East Sussex
- Paperwork
- Photo report after each visit
- Quotes
- A fixed price before we start
- Hours
- Evenings, overnight and weekends; 24/7 emergencies
- Telephone
- 0345 646 2711
- Updated
- 30 October 2026
Extract fans in Pell Green
Food Standards Agency data counts about 3 restaurants, cafés and works canteens and about 3 takeaways in and around Pell Green, up to about a mile and a half out. A kitchen with a dead extract fan gets hot and smoky fast, and kitchens like these feel it at once. Pell Green is about 35 miles from central London, well within the area we cover across London and the South East. We work evenings, overnight and at weekends, so the visit fits around the site. Kitchens in Pell Green get their food hygiene inspections from Wealden council. Ventilation is part of food hygiene law, which expects it to be suitable and sufficient. That makes a fan repair urgent rather than something to put off.
If you run a church or community hall kitchen, near Rehoboth Chapel or elsewhere in Pell Green, an extract fan that rarely runs can seize or fail when it’s needed.
Pell Green is about 6 miles south-east of Royal Tunbridge Wells, in East Sussex. Sites in Pell Green get the same service as everywhere we cover: diagnosis first, a fixed price, out-of-hours working where necessary and a written report with photos. Pell Green is one of 289 towns, villages and districts in East Sussex we cover for extract fan repair. There’s also a page for Maidstone, about 15 miles away.
All of TN5 is covered for extract fan repair, from busy streets to back roads. We also cover Newbury's (1 mile north-east), Cousley Wood (1 mile north-east), Wadhurst (1 mile south-west), Birchett's Green (2 miles south-east) and Shover's Green (2 miles south). We also work in nearby towns such as Hailsham (15 miles south), Crowborough (8 miles west), Uckfield (13 miles south-west), Heathfield (8 miles south-west), Upper Horsebridge (14 miles south) and Hellingly (14 miles south).
Around Pell Green
Locally, jobs take us to businesses close to Uplands Community College and The Old Vine Public House and the streets around them. The nearest railway station is Wadhurst station, roughly 1.5 miles west of the centre. Well-known places in the area include Ticehurst House Hospital (2.8 miles south-east) and Old Scotney Castle (3.1 miles north-east). Open spaces near Pell Green include Bewl Water.
For landlords and multi-site operators
Landlords, managing agents and facilities managers book us, not only the businesses that use the systems. Where a system serves more than one tenant, such as a shared riser, it helps to agree who arranges the work, and we’re happy to quote for all of it.
Where a tenant occupies the premises but the landlord owns the building, the lease normally sets out who maintains what. We can quote either party, and the report can go to both.
Why act early in Pell Green
Wherever the kitchen is, Pell Green included, the fan often sits on an outside wall or roof, where a rattle or a whine can be heard beyond the kitchen. Fixing the cause quietens it down before neighbours notice. Rural sites can’t always move to another kitchen or room when something fails.
No two sites are the same, so each one gets its own fixed quote. The size of the job, how we reach it, its condition and the working hours all make a difference.
Why book with us
- A BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease
- A fixed price before any work starts
- In business since 2009
- Fully insured
Take a look at our cost guide or our accreditations.
What we are called out for in Pell Green
Fixings and anti-vibration mounts work loose or perish over time. Then every vibration is passed into the duct and the building, which is where knocking and rattling often come from.
It’s time to book a visit if you see:
- A fan that keeps cutting out
- An extract that vibrates through the ductwork
- A whining or grinding extract motor
- A belt-driven fan that squeals
If you run a school kitchen, at a school such as Wadhurst CofE Primary School or nearby, a fan that is getting noisy is best repaired in the holidays before it fails in term.
Comparing quotes
- Whether they recommend a next date
- Proof of accreditation you can verify
- Whether the quote is based on a survey or photos
- Whether they’re fully insured
The process
Protection comes first: sheeting goes over floors and surfaces close to the work. Then we make the system safe and start. The work on site takes a few hours for most repairs, longer for a full fan replacement, and we clear up before we go. In a small place like Pell Green, the journey is planned ahead and the visit arranged around the site’s hours.
- We start with the symptoms, such as rattling, humming, slow running or a fan that will not start.
- Power to the fan is isolated before we open the housing.
- We check the motor, bearings, drive, impeller and mountings.
- You get our diagnosis and a fixed quote to repair or replace.
- The repair or replacement is carried out and the fan is run and checked.
Preparing for the visit
- Mention any locked doors, roof access or ceiling voids
- Allow time for equipment near the work to be turned off and cool down
- Tell us where we can park and unload
Ask for a quote
Quoting starts with a diagnosis, from your photos and details or, where that is not enough, a survey on site. After that, you get a fixed price for the work, before work begins.
Advice
Your questions about extract fan repair in Pell Green
Which environmental health team covers Pell Green?
Kitchens in Pell Green are inspected by Wealden council’s environmental health officers. If the extract fan has failed, it’s worth having the repair booked, and the details to hand, before an officer visits.
Who do I call if an extract fan fails in Pell Green?
Day or night, a failed fan in Pell Green can be reported on our emergency line. Call 0345 646 2711 and tell us what the fan is doing, or not doing. A photo of the fan’s rating plate helps.
Can you supply and fit a replacement fan?
We can. Replacing a fan is part of our fits and repairs work, and we’ll explain the options.
Will you tell us when the next visit is due?
Yes. The recommended date is on the report. BESA’s minimum intervals for kitchen extracts range from 3-monthly for heavy use to 12-monthly for light use, and fire dampers need testing at least once a year.
Do you look at the system first?
Yes, always. We diagnose before we treat: the survey tells us what the system needs and how to reach it and the fixed quote is built on it.
What does TR19 mean?
A BESA specification in two main parts: TR19® Grease for kitchen extract systems and TR19® Air for general ventilation. It is not legislation, but it’s the standard people check against.
What about areas you can’t get to?
Anything we can’t reach goes on the report, with a note of where it is, and we tell you what would make it reachable, for example new access panels.
What accreditations do you have?
We are a BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease. CHAS, SafeContractor and ISO 9001 are in place too, and we are fully insured.
What affects the quote in Pell Green
A fixed price needs a few facts first. We look at:
- Parking and loading at the site
- How big the system is
- What state the system is in
- Site rules, permits and inductions
One small site or a whole estate, the quote is built the same way: the work involved, the access and the timing. You will have a fixed price before we start.
What to send for a quote
When you call or email, these details help:
- When the site is open and when it’s quiet
- Any previous report or certificate
- Any access panels or hatches you can see
- Photos showing the whole system and its surroundings
Photos are enough for some jobs, while others need a look on site. Big or complicated sites, and systems that are hard to see in pictures, get a survey first. Either way, the quote is fixed before any work is booked.
Towns and villages near Pell Green
What else we do in Pell Green
When it’s something else
We’d rather tell you now than book work that will not help, so here are the limits:
- Problems with the electrical supply to the fan (an electrician’s job)
- Smells from the discharge that need odour control equipment
- Ductwork designed too small for the kitchen’s cooking
If you’re not sure, just call 0345 646 2711 or send us an email and we’ll give you a straight answer before booking.
What we work on in Pell Green
- Kitchen extract fans
- Bearings
- Fan motors
- Fan housings
- Roof and wall fans
- Belts and pulleys