Kent · TR19 inspections and grease testing
TR19 inspections and grease testing in Newtown, Kent
TR19 inspection across Newtown and nearby, booked around your opening hours and finished with a written report and pictures.
- Missing access panels found on survey
- Pre-clean surveys before a first TR19 clean
- Sites with gaps in their extract records
TR19 inspection in Newtown
Post-clean verification is a check carried out once the cleaning is done, with new readings and pictures of the cleaned areas. It shows whether the system was left in the condition the paperwork describes. If you have sections of duct that can’t be reached and ductwork where grease may be over the TR19 limits, we can put it right, from wet film thickness tests, pre-clean surveys and post-clean checks onwards.
Size doesn’t change the work: a kitchen in a place like Newtown gets the whole system cleaned, canopy to discharge. The visit is booked around your opening hours, and the journey is planned ahead.
Good records are part of the job. Each visit is written up with photos, listing what was done, anything we couldn’t reach and when the next visit is due. Keep it with your fire safety records so it’s to hand when an insurer or inspector asks.
- Location
- Newtown (TN24, TN23)
- Wider area
- Kent
- Paperwork
- TR19® certificate and photo report
- Price
- Fixed quote, normally within a working day
- Working hours
- Out of hours as standard, 24/7 emergency line
- Phone
- 0345 646 2711
- Checked
- 30 October 2026
Aftercare tips
How long the results last depends on use and care. We suggest:
- Book the next test on the date in the report
- Keep canopy edges and gutters wiped down
- Report grease dripping from the canopy
- File every inspection report with your certificates
The report recommends when the system should next be cleaned and tested, based on the readings and how the kitchen is used.
Keep filters clean and in place. Missing or damaged filters let grease straight into the plenum.
What we do, step by step
Before we leave, we walk the area with whoever is on site. Anything we couldn’t reach or that needs attention is pointed out there and then, and it goes on the report too. The visit takes around an hour or two per canopy and duct system. Your opening hours decide when we come to Newtown, not ours.
- We go through any past certificates and reports.
- We follow the extract from canopy to discharge.
- We note where access panels are and where more are needed.
- Grease readings are taken and photos recorded.
- You get a report and a fixed quote for the clean.
Getting ready for the visit
- Dig out any earlier paperwork for the system
- Clear loose items from the work area
- Plan for cooking equipment or plant to be off before we arrive
Ask for a quote
Want a quote for TR19 inspection? Please call us on 0345 646 2711, or email photos and tell us about the site. We will explain what we’d do and send a fixed quote before anything is booked.
Advice
Part by part
Canopy and plenum
The canopy itself is checked inside and out, and note where grease has gathered.
Horizontal duct runs
Bends and long runs can hold heavy deposits, out of sight of the kitchen.
How we price TR19 inspection
Some jobs are bigger than they look, and some smaller. The main factors:
- The number of sites or systems
- Whether we need access equipment or extra panels
- The times the site is available
- Where the site is and how we reach it
You won’t find a price list here, because the cost depends on the site in front of us. For a fixed quote, phone us on 0345 646 2711 or send us an email, and we will talk you through it.
Helping us quote
Photos and a few facts are often enough to price the work. Send what you can of the following:
- Problems your staff have spotted
- The roof, plant room or outside wall the system runs to
- The times we could work without disrupting the site
- The postcode and the type of business
To help us quote: the address, the type of site and when it’s open, pictures of the system and the last certificate or report, if there is one. Then ring 0345 646 2711 or use the quote form.
When something else is needed
We will always give you a straight diagnosis, so here’s what TR19 inspection will not do:
- Sections with no access, until panels are fitted
- Ductwork that was designed or installed badly
- A faulty or failing extract fan
Not sure which it is? You can ring 0345 646 2711, or email photos and we’ll tell you honestly.
Where we work
- Wet film thickness tests
- Insurer audits
- Pre-clean surveys
- Deposit thickness tests
- Access surveys
- Post-clean checks
Places near Newtown
Other services in Newtown
TR19 inspection around Newtown
The FSA’s food hygiene register shows about 89 restaurants, cafés and works canteens and about 32 sandwich bars and takeaways in and around Newtown, up to about a mile and a half out. A WFTT or DTT reading tells each of those kitchens whether its grease is staying under the 200-micron mean. Newtown is covered by Kent Fire and Rescue Service. Grease in a kitchen extract is a recognised fire risk, and the fire authority enforces the law on managing it in most commercial premises. It’s Ashford council that sends environmental health officers to food businesses in Newtown. They look at how clean the premises and equipment are, and the kitchen extract is part of that. Keeping each certificate and photo report on file helps show the extract is looked after.
If you run a church or community hall kitchen, near Christ Church or elsewhere in Newtown, its extract still collects grease from every lunch and event. Commuter trade near Ashford International station can mean long cooking hours, and long hours put a kitchen into BESA’s more frequent cleaning bands.
Newtown is about 1 mile south-east of Ashford, in Kent. Every kind of commercial site in Newtown, we can take on TR19 inspection. We can work out of hours so trading is not interrupted. 922 places in Kent are on our list, large and small. Our Maidstone page covers sites nearby, about 18 miles away.
Postcode districts we cover here for TR19 inspection: TN24 and TN23. We cover sites on Bath Road, Mead Road and Royds Road and the roads around them. Nearby, we also carry out TR19 inspection in South Willesborough (1 mile north-east), Park Farm (1 mile south-west), Willesborough (1 mile north-east), Ashford (1 mile north-west) and Finberry (1 mile south-east). We also work in nearby towns such as Canterbury (14 miles north-east), Folkestone (13 miles east), Faversham (13 miles north), Hythe (10 miles south-east), Davington (13 miles north) and Preston (12 miles north).
Around Newtown
Locally, jobs take us to businesses close to The North School, The Albion Inn and Ashford Green Corridors and the streets around them. The nearest railway station is Ashford International station, about 0.9 miles north of the centre. Well-known places in the area include Ashford Designer Outlet (0.5 miles north) and William Harvey Hospital (1.7 miles north-east). For a walk, there’s Hatch Park.
Signs you need TR19 inspection in Newtown
Some parts of a system are hard to reach, so those sections can be skipped time and again. A survey finds the sections that cannot be reached, so panels can be fitted.
Most sites get in touch when they notice something like this:
- Surveys needed before quoting a full clean
- Uncertainty over how often to clean
- Parts of the system left out of past cleans
- An insurer’s request for a TR19 audit
Bursars and site managers at schools such as East Stour Primary School tend to book extract cleaning for when the kitchen is empty.
What your quote should include
- Whether the figure could change on the day
- Whether inaccessible sections are listed on the report
- What records you’ll receive afterwards
- If they look at the system before pricing
Newtown: your questions answered
Which fire authority looks after Newtown?
It’s Kent Fire and Rescue Service, which covers Newtown. TR19® is not law, but it’s the benchmark many fire officers and insurers look to when they ask how often the extract is cleaned.
Who would carry out a food hygiene inspection at a kitchen in Newtown?
In Newtown, it’s Ashford council that carries out food hygiene inspections. An officer may look up into the canopy, so clean filters on the day and a recent certificate on file both help.
What is post-clean verification?
It’s an inspection after cleaning, to show what state the system was left in, for our cleans and other firms’ alike.
Do you work in Newtown?
Yes. Newtown is part of the area we cover, as part of our area across London and the South East.
Do you work out of hours?
Yes. Give us your opening hours with your enquiry and we’ll book around them.
How much notice should we give?
The more notice, the better, especially for out-of-hours work. Quotes normally come back within one working day, and emergencies are covered by our 24/7 line.
Can we book visits on a schedule?
Yes. Regular plans can run on 3, 6 or 12-monthly cycles, depending on what the system needs.
What does a pre-clean survey involve?
The survey covers the whole system, grease readings and access to each section. From it, we plan the clean and quote a fixed price.
Managing agents and facilities teams in Newtown
For anyone managing more than one site, we can schedule visits across all of them on one quote. Every building has its own written report, so records stay tidy.
Under the Regulatory Reform (Fire Safety) Order 2005, the responsible person must assess and reduce fire risk, and that can be the employer, the owner, a landlord, a facilities manager or a managing agent. Where responsibility is shared, records matter even more.