Kent · Extract fan repair and replacement
Extract fan repair and replacement in Sutton, Kent
Repair and replacement of kitchen extract fans, fan motors and worn fan parts in Sutton, surveyed first and signed off with a written report and photos. Ask us for a fixed quote.
- An extract fan that has stopped working
- A squealing belt on start-up
- A fan rattling in its housing
When a fan fails in Sutton
Sutton lies within about 3 miles of the sea. A fan exposed to sea air needs its fixings and housing checked more often than one inland. In Sutton, food businesses are inspected by environmental health officers from Dover council. A kitchen with no working extract can fall short of the suitable and sufficient ventilation food hygiene rules expect. Getting the fan running again is the priority.
Occasional-use kitchens, such as a hall kitchen near Church of St Peter and St Paul or elsewhere in Sutton, are where a stiff or seized fan can turn up.
Sutton is about 3 miles south-west of Deal, in Kent. Whether your site is in the middle of Sutton or further out, we cover extract fan repair for every kind of premises, from small sites to large estates. 922 places in Kent are on our list, from busy centres to quieter spots. You can also see our page for Maidstone, roughly 36 miles from Sutton.
We cover every part of CT15 for extract fan repair and the streets around it. Whether your site is on Vale Road and Church Hill or a nearby road, we can help. Nearby, we also carry out extract fan repair in East Studdal (1 mile west), Martin (1 mile south), Studdal (1 mile west), Ringwould (2 miles south-east) and West Langdon (2 miles south-west). Within a short drive, we also cover Canterbury (13 miles north-west), Margate (13 miles north), Dover (4 miles south-west), Folkestone (11 miles south-west), Ramsgate (10 miles north) and Broadstairs (12 miles north).
What’s near Sutton
The closest station to Sutton is Martin Mill station, about 1.7 miles south of the centre. A little further out are Royal Victoria Hospital (4.9 miles south) and Kent Museum of the Moving Image (3.2 miles north-east).
Extract fan repair in Sutton, done properly
A faulty fan doesn’t always mean a new one. Often a clean, a new belt or new bearings brings it back, and that is what we will recommend. When a fan is worn beyond sensible repair, a replacement suited to the system goes in. The work covers fan housings, bearings and roof and wall fans, and the jobs we see most are a squealing belt on start-up and a failed fan that needs a replacement.
For a fan repair in or near Sutton, the more you tell us about the fan, the better the first visit: pictures of the fan, its rating plate and how to reach it all help.
A written report with pictures follows each visit, so you have a record of what was done and when. Where the work is a TR19® Grease clean, the certificate is issued through the BESCA Vent Hygiene Elite portal.
- Where
- Sutton (CT15)
- Region
- Kent
- Records
- Written report with photos
- Quotes
- Fixed quote, normally within a working day
- Working hours
- Overnight and weekend work, 24/7 emergency callout
- Telephone
- 0345 646 2711
- Last updated
- 30 October 2026
Part by part
Fan controls
Controls are checked as well as the fan itself, because a fan that won’t start isn’t always a failed motor.
Impellers and housings
Where an impeller is bent or corroded, cleaning will not help. It may need replacing, or the fan may need replacing as a whole.
Why act early in Sutton
Weak extraction leaves heat, smoke and fumes in the kitchen. Staff work in hotter, steamier air and grease has more chance to settle on surfaces and in the duct. Systems in rural buildings are often out of sight and out of mind.
Leaving it longer rarely makes the work cheaper. Build-up, wear and faults tend to get worse, not better, which can make the next visit longer. If you are not sure what’s needed, give us a ring on 0345 646 2711, or email photos for straight advice and a fixed quote.
What you get with us
- Member of BESCA Vent Hygiene Elite, cleaning to BESA TR19® Grease
- Evenings, overnight and weekends, plus 24/7 emergency callout
- One contact for all your sites in London and the South East
- Trading since 2009
Take a look at our cost guide or how to check a contractor.
How it works
Protection comes first: sheeting goes over floors and surfaces close to the work. After that, the system is made safe and the work begins. The work on site takes part of a day for most faults, with a return visit if parts have to be ordered, and the area is cleaned down before we leave. The timing of a visit to Sutton is set by you, and the travel is our side of the planning.
- We take details of the symptoms and book a time that suits the kitchen.
- We isolate the fan before touching it.
- The fan and its controls are checked to pin down the fault.
- A fixed quote for the repair or replacement follows.
- The work is done and the fan is tested running.
Preparing for the visit
- Dig out any earlier paperwork for the system
- Mention any locked doors, roof access or ceiling voids
- Make sure equipment near the work can be switched off and left to cool
Get a fixed quote
Quoting starts with a diagnosis, either from pictures and details you send or from a site visit. After that, you get a fixed price for the work so you know the cost before any work starts.
Related advice
Nearby places to Sutton
Other services in Sutton
Between visits
Aftercare is simple, and it helps at the next visit:
- Save our number for the 24/7 emergency line
- Make sure the fan is cleaned with the rest of the system
- Make sure the isolator and controls are easy to reach
- Avoid lowering the speed to quieten a fault
Where parts need ordering, we explain what that means for the kitchen until we return. The fan is completed on a return visit outside your busiest hours.
A fan that is starting to make noise is giving you a warning. Booking a check at this stage keeps it a planned job rather than an emergency during service.
Your questions about extract fan repair in Sutton
Does being near the coast affect extract fan repair in Sutton?
It can. Sutton is within about 3 miles of the coast, and salt air speeds up corrosion. Outdoor metalwork near the sea is worth inspecting at each visit.
Can you come out to a failed extract fan in Sutton out of hours?
We run a 24/7 emergency line for failed extract fans, and Sutton is part of our area. Ring 0345 646 2711 at any hour and describe the fault. If you can, stop cooking until the fan is checked.
What happens to the waste?
We take it away when we go. During the work, it’s contained to keep the area clean.
Can we book visits on a schedule?
Yes, of course. Tell us what you have and how it’s used and we’ll propose a schedule with a fixed quote.
Why is our extract fan so noisy?
Grease on the blades throws the fan out of balance and that is one of the most common reasons. Worn bearings, belts and loose mounts are others.
Who has the legal duty for fire safety?
The law calls them the responsible person. It’s normally the employer, or whoever controls the building, and where several people have control, each can have duties. Your lease and fire risk assessment should make it clear.
Can you supply and fit a replacement fan?
We do. A replacement is matched to the system it’s going into with a fixed price agreed before we start.
Is it worth cleaning the extract while you are fixing the fan?
Repairing the fan does not clean the canopy or ducts. Grease on the fan typically means grease in the ducts and we can plan the two together.
When something else is needed
Extract fan repair can’t fix everything, and we’ll tell you before we start. It will not put right:
- Gas interlock faults that a Gas Safe registered engineer must deal with
- An extract system that was undersized from the start
- Faults in the building’s electrical supply, which need an electrician
If in doubt, ring 0345 646 2711 or drop us a line and we will say what we think before booking.
Where we work
- Roof and wall fans
- Fan housings
- Belts and pulleys
- Kitchen extract fans
- Fan motors
- Bearings
For landlords and multi-site operators
Where a tenant occupies the premises but the landlord owns the building, it’s worth checking the lease for who maintains the systems. We can quote either party and send the paperwork to whoever needs it.
We regularly work with managing agents. Send the address, what’s needed and how access works and we will come back with a fixed quote.
Signs you need extract fan repair in Sutton
Fixings and anti-vibration mounts work loose or perish over time. The fan’s movement then travels into the ductwork and structure, which is where knocking and rattling often come from.
Common reasons sites call us are:
- A fan that keeps cutting out
- A fan worn beyond sensible repair
- An extract fan that has stopped working
- A worn or slipping fan belt
Around Sutton, a failed fan can be reported day or night on our 24/7 line.
Before you book anyone
- Whether VAT is included
- Proof of insurance
- Whether inaccessible sections are listed on the report
- Whether a survey comes first