Kent · Extract fan repair and replacement
Extractor fan repair in Elham
Professional extract fan repair in and around Elham, booked around your opening hours and finished with a written report and photos.
- A humming noise from the fan motor
- A fan worn beyond sensible repair
- Vibration spreading from the fan into the ducts
Extract fan repair for kitchens and businesses in Elham
Everything a kitchen extract does depends on the fan. When it starts to rattle, hum or slow down, the cooking area soon fills with heat and fumes. We find out why and put it right, by repairing the fan or replacing it. Typical jobs include a knocking noise from the extract fan and a squealing belt on start-up, across roof and wall fans, kitchen extract fans and bearings.
In a small place like Elham, fans are often on an outside wall or roof, open to wind and rain. That, with the grease, is hard on motors and bearings.
We have been trading since 2009, as a BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease. We also hold CHAS, SafeContractor and ISO 9001, and we are fully insured.
- Place
- Elham (CT4)
- Region
- Kent
- Records
- Written report with photos
- Quote
- A fixed quote up front
- Hours
- After hours by arrangement; emergencies any time
- Telephone
- 0345 646 2711
- Updated
- 30 October 2026
Common problems we fix in Elham
Fixings and anti-vibration mounts work loose or perish over time. The fan’s movement then travels into the ductwork and structure and that is a common source of rattles.
Clients usually contact us after spotting something like this:
- Weak extraction and a smoky kitchen
- An extract fan that rattles or knocks
- Vibration spreading from the fan into the ducts
- A fan that keeps cutting out
Holidays are the time to replace a tired kitchen fan at schools such as Elham Church of England Primary School, rather than mid-term.
Comparing quotes
- Whether the quote shows VAT
- Exactly which parts of the system are covered
- How they set the interval to the next visit
- What happens if part of the system cannot be accessed
In-house cleaning or a specialist?
Your own staff can handle the daily basics: wiping canopies, washing grease filters and recording it in a log. Inside the ducts, risers and fan is specialist work, and that’s where we come in.
Logging matters as much as cleaning. A simple log of filter washes, wipe-downs and checks helps show that the system is managed between specialist visits, alongside our reports.
What a clean will not put right
A few issues sit outside what this work can do:
- A greasy canopy and duct that a fan repair won’t touch
- Smells from the discharge that need odour control equipment
- Faults in the building’s electrical supply, which need an electrician
If in doubt, call us on 0345 646 2711 or send us an email and we’ll say what we think before you book.
What the work covers
- Belts and pulleys
- Bearings
- Kitchen extract fans
- Roof and wall fans
- Fan motors
- Fan housings
Keeping the system healthy
How long the results last depends on use and care. We suggest:
- Never run the extract with filters missing
- Do not turn the fan down to hide a noise
- Make sure every filter is in place and clean
- Don’t wait for a noisy fan to stop
Before we leave, the fan is run and checked. We explain the fault and the fix along with anything else that needs watching.
The fan is part of every full TR19 clean. A clean impeller stays in balance and that means less wear.
Why act early in Elham
An overloaded motor is under constant strain. Every hour of strain takes its toll and a burnt-out motor is a bigger job than a worn belt. Early attention keeps the cost and disruption down. Out of sight is the usual reason a rural system goes too long without attention.
Putting the work off seldom saves money. Build-up, wear and faults tend to get worse, not better, and a neglected system can mean more work. If you are not sure what’s needed, give us a ring on 0345 646 2711, or email photos for straight advice and a fixed quote.
Why Elham businesses choose us
- One number for every site across the South East and London
- Photo reports with every job
- CHAS and SafeContractor accredited, with ISO 9001
- We diagnose before we treat
What happens on the day
Our technicians bring everything the work needs, including protection sheets, the right tools and access kit. You only need to give us clear access and switch off what needs to be off. The visit takes a few hours for most repairs, longer for a full fan replacement. We agree a date with you, plan the drive to Elham and turn up when the site is quiet.
- We ask what the fan is doing, from noise and vibration to a full stop.
- Power to the fan is isolated before we open the housing.
- Each part is checked in turn: motor, bearings, drive, impeller and fixings.
- We explain the fault and give you a fixed price for the fix.
- Once the work is done, we run the fan and check it’s steady and quiet.
Preparing for the visit
- Make sure equipment near the work can be switched off and left to cool
- Agree a time when the area can be out of use
- Clear loose items from the work area
How to get a quote
If you need extract fan repair in Elham, call us on 0345 646 2711 or email us. Tell us what kind of premises it is and when it’s open, and send photos or your last report if you can. A fixed quote typically follows within one working day.
Advice
Common questions in Elham
Which council inspects kitchens in Elham?
In Elham, it’s Folkestone and Hythe council that carries out food hygiene inspections. An officer may ask how the kitchen is ventilated, so keep repair records with your maintenance file.
Can you get to a site in Elham?
Yes. Villages and rural sites across the South East are part of our work, Elham included. Let us know about access, parking and anything unusual about getting there when you book.
What happens if you cannot reach some of it?
The report shows them clearly. Often the fix is extra access, such as new panels in ductwork, which we can install.
What is TR19?
BESA’s ventilation hygiene specification in two main parts: TR19® Grease for kitchen extract systems and TR19® Air for general ventilation. It isn’t legislation, but it’s the standard people check against.
Do you provide a certificate or report?
Yes. Each visit ends with a written report and photos, showing what was done, anything we couldn’t reach and when the next visit is due. Where the work is a TR19® Grease clean, there’s also a certificate issued through the BESCA Vent Hygiene Elite portal.
What paperwork should we keep on file?
Visit reports, certificates and your in-house cleaning logs. They’re what an insurer, fire officer or EHO may ask for, so keep them together and easy to find.
Which accreditations do you hold?
Duct Doctor is a BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease. CHAS, SafeContractor and ISO 9001 are in place too, and we carry full insurance.
What do you do to protect the area?
With sheeting and covers, before anything else happens. We keep the work contained and leave the area clean.
Extract fans in Elham
Kitchens in Elham get their food hygiene inspections from Folkestone and Hythe council. A kitchen with no working extract can fall short of the suitable and sufficient ventilation food hygiene rules expect. That’s one more reason not to keep cooking with a broken fan. About 57 miles out from central London, Elham is part of the South East area we work across. Evening, overnight and weekend visits are all possible.
If you look after a church or hall kitchen near Church of St Mary the Virgin, or anywhere in Elham, test the extract fan before a big event rather than on the day.
Elham is about 5 miles north-west of Folkestone, in Kent. Sites in Elham get the same service as everywhere we cover: a survey first, a fixed quote, work timed around your hours and a report with pictures. Our area takes in 922 places across Kent, from busy centres to quieter spots. We also work in Maidstone, around 26 miles away.
Every address in CT4 is covered for extract fan repair, from busy streets to back roads. We cover sites on High Street, Pound Lane and Vicarage Lane and nearby roads. We also cover the places around Elham: Swingfield Minnis (2 miles east), Densole (3 miles south-east), Selsted (3 miles east), Breach (3 miles north-east) and Lodge Lees (3 miles north-east). We also work in nearby towns such as Ashford (11 miles west), Canterbury (9 miles north), Dover (8 miles east), Folkestone (5 miles south-east), Whitstable (14 miles north) and Deal (13 miles east).
Around Elham
We work in commercial kitchens and buildings around The King's Arms, among other places. For rail, the closest station is Sandling station, about 4.7 miles south-west of the centre. Nearby you will also find Royal Victoria Hospital (5.3 miles south-east) and Elham Valley Countryside Centre And Railway Museum (3.7 miles south). Not far away are Cheriton Hill.
What else we do in Elham
Part by part
Impellers and housings
Grease settles inside the fan housing as well as on the blades. Both are inspected and cleaning may be part of the fix.
Fan controls
Every fan has controls, from a speed controller to an isolator. When they fail, the fan may not start or may run at the wrong speed.