East Sussex · Extract fan repair and replacement
Extractor fan repair in Crumbles
Extract fan repair for commercial sites in Crumbles and across East Sussex. CHAS, SafeContractor and ISO 9001, and fully insured.
- A fan that will not start at all
- An old fan that needs replacing
- An extract that vibrates through the ductwork
Fixed quotes for extract fan repair in Crumbles
The quote reflects the site in front of us. We consider:
- Travel, parking and unloading
- The condition we find in the survey
- How many systems or sites are involved
- Any permits to work or inductions
One small site or a whole estate, we price it on the same basis: the work involved, the access and the timing. You’ll have a fixed price before we start.
Asking for a quote
What to send for a quote:
- Anything you’ve noticed, such as smells, noise, drips or poor airflow
- The times we could work without disrupting the site
- Where the plant sits or the system leaves the building, such as a roof or outside wall
- Detail shots of panels, filters and grilles
Photos are the quickest way to a quote: the system from a couple of angles, plus any access panels or hatches. Tell us what kind of site it is and when it’s open, and many jobs can be priced from that alone.
About our extract fan repair in Crumbles
Kitchens in Crumbles call us about extract fans and motors that are noisy, slow or dead, we find the cause and quote a fixed price to repair or replace it. For a fan that fails during service, there’s a 24/7 emergency callout. Common call-outs are for a failed fan that needs a replacement and a humming noise from the fan motor, across belts and pulleys, kitchen extract fans and fan housings.
Rural kitchens often have fans mounted on outside walls or roofs, exposed to the weather. That, with the grease, is hard on motors and bearings.
Duct Doctor has been trading since 2009, and we’re a BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease. We also hold CHAS, SafeContractor and ISO 9001, and we’re fully insured.
- Place
- Crumbles (BN23)
- Wider area
- East Sussex
- Reporting
- Report and pictures after the visit
- Quote
- A fixed quote up front
- Hours
- Evenings, overnight and weekends; 24/7 emergencies
- Telephone
- 0345 646 2711
- Page updated
- 30 October 2026
Extract fans in Crumbles
Sea air reaches Crumbles, which sits within about 1 mile of the coast. Near the sea, fans mounted outdoors corrode faster, and corroded fans tend to get noisy before they fail. Look up Crumbles on the FSA’s food hygiene register and you will find about 34 restaurants, cafés and works canteens and about 11 takeaways within roughly a mile and a half of the centre of Crumbles. Those that cook under a canopy rely on a fan that runs every hour they’re open. Environmental health officers from Eastbourne council inspect food businesses in Crumbles. Food hygiene rules expect food premises to have suitable and sufficient ventilation. A kitchen without a working fan has a problem to fix quickly.
A fan that rarely runs, like one in a hall kitchen near St. Richard or elsewhere in Crumbles, can seize between uses. For school kitchens, at schools like St Catherine's College for example, a planned fan repair in the holidays avoids losing lunches in term time.
Crumbles is about 2 miles east of Eastbourne, in East Sussex. Every kind of commercial site in Crumbles, we can take on extract fan repair. We can work out of hours so the site keeps running. Our area takes in 289 places across East Sussex, from busy centres to quieter spots. We also work in Brighton, about 20 miles from Crumbles.
Here we cover the BN23 postcode area for extract fan repair. That includes premises on Tambora Square, Long Beach View and Golden Gate Way and the roads around them. We also cover the places around Crumbles: Langney (1 mile west), Pevensey Bay (1 mile north-east), Pevensey (2 miles north), Westham (2 miles north-west) and Stone Cross (2 miles north-west). Larger places within reach include Hastings (11 miles north-east), Bexhill-on-Sea (7 miles north-east), Seaford (10 miles west), Lewes (15 miles west), Hailsham (6 miles north-west) and St Leonards (10 miles north-east).
Local landmarks in Crumbles
Around Crumbles, our work takes us to kitchens and buildings near The Haven Voluntary Aided CofE/Methodist Primary School and Princes Park, among other places. The closest station to Crumbles is Pevensey & Westham station, roughly 1.3 miles north. A little further out are Pevensey Court House Museum And Gaol (1.6 miles north) and Pevensey Castle (1.5 miles north). For a walk, there’s Combe Hill.
Managing agents and facilities teams in Crumbles
The Fire Safety Order 2005 puts the duty to manage fire risk on the responsible person, and that can be the employer, the owner, a landlord, a facilities manager or a managing agent. Where responsibility is shared, records matter even more.
We work for landlords, managing agents and facilities managers as well as the people running the site. Where a system serves more than one tenant, such as a shared riser, it helps to agree who arranges the work, and we can quote for the whole system.
Keeping the system healthy
Once we’ve finished, these simple steps help:
- Get a noisy fan checked rather than slowed down
- Make sure the fan is cleaned with the rest of the system
- Keep the area around the fan controls clear
- Save our number for the 24/7 emergency line
Grease on the fan typically means grease in the duct as well. A full TR19® clean deals with the canopy, ductwork and fan together and you get a TR19 certificate and photo report afterwards.
Small faults, like a worn belt, are quick to fix. Left for months, they can damage the motor or bearings so early attention pays.
Crumbles questions
Do you cover Crumbles for emergency fan repairs?
Our emergency line runs 24/7, and Crumbles is within the area we cover. Ring 0345 646 2711 at any hour and describe the fault. A photo of the fan’s rating plate helps.
Which environmental health team covers Crumbles?
Food hygiene inspections in Crumbles are carried out by Eastbourne council. Keeping the fan serviced is easier than explaining a broken one on inspection day.
What do you do to protect the area?
We cover floors and nearby surfaces with sheeting before any work starts, and anything we remove is contained. At the end, the area is cleaned down.
Do you have insurance?
Yes. Full insurance covers our work, and we have been trading since 2009.
What will a fan repair or replacement cost?
We can’t price it without knowing the fault. After we’ve checked the fan, we give you a fixed price for the repair or the replacement.
Why is our extract fan so noisy?
Grease on the blades throws the fan out of balance and that is one of the most common reasons. Worn bearings, belts and loose mounts are others.
Is TR19 cleaning required by law?
No. The law sets the duty; TR19® is the benchmark used to show it’s met. Under the Regulatory Reform (Fire Safety) Order 2005, the responsible person has to manage fire risk, and without records, many insurers may refuse or reduce a claim.
Will we have to shut during the visit?
Not usually. The area we are working in has to be out of use while we’re there, so we book a time when it would be closed anyway.
What extract fan repair can’t fix
It’s worth knowing the limits before booking:
- A greasy canopy and duct that a fan repair will not touch
- Faults on the gas side of an interlock system, which need a Gas Safe registered engineer
- Problems with the electrical supply to the fan (an electrician’s job)
If in doubt, ring 0345 646 2711 or send us an email and we’ll say what we think before you book.
Parts of the system we cover
- Bearings
- Kitchen extract fans
- Belts and pulleys
- Roof and wall fans
- Fan housings
- Fan motors
Nearby places to Crumbles
Also in Crumbles
Why deal with it now?
An overloaded motor is under constant strain. That shortens its life and a burnt-out motor is a bigger job than a worn belt. Early attention keeps the cost and disruption down. Systems in rural buildings are often out of sight and out of mind.
Putting the work off seldom saves money. Problems in a system tend to grow, and a neglected system can mean more work. If you are not sure what’s needed, call us on 0345 646 2711, or email photos and we will give you an honest view and a fixed quote.
Why book with us
- Each visit written up, with photos
- Out-of-hours work and a 24/7 emergency line
- Accredited under CHAS and SafeContractor, with ISO 9001
- A single point of contact for sites across the South East and London
Read what affects the cost and our accreditations and certificates.
What your team can do, and what needs us
Some jobs should never be done in-house: entering ducts, working on fans, testing dampers and taking grease readings call for the right kit, training and safe access. That is our job.
Staff cleaning and specialist work aren’t the same thing. Wiping filters daily and washing them weekly keeps the visible parts in order, but grease that has passed the filters is out of reach. That part needs specialist access and equipment.
What we do, step by step
Your staff don’t need to do much on the day. A contact on site lets us in at the agreed time and points us to the system, and the rest is down to us. Before we leave, the area is tidied and the paperwork follows. If you can send photos, we can arrive in Crumbles knowing what to expect.
- You describe the fault and we arrange a visit.
- On site, the fan is safely isolated.
- We diagnose the fault, checking the controls as well as the fan.
- You get a fixed price for putting it right.
- The work is done and the fan is tested running.
Before we arrive
- Allow time for equipment near the work to be turned off and cool down
- Mention any locked doors, roof access or ceiling voids
- Tell us where we can park and unload
How to get a quote
To help us quote: the address, the type of site and when it’s open, photos of the system and any previous report or certificate. Then ring 0345 646 2711, or send details by email.