East Sussex · Extract fan repair and replacement
Extractor fan repair in Chiltington
For repair and replacement of kitchen extract fans, fan motors and worn fan parts in Chiltington, one call is all it takes, from survey to sign-off. CHAS and SafeContractor accredited, ISO 9001 and fully insured.
- A failed fan that needs a replacement
- A knocking noise from the extract fan
- A fan that will not start at all
The process
Each visit runs to the same pattern: sheeting and protection first, make the system safe, carry out the extract fan repair, clear away and hand over the paperwork. The visit itself takes a few hours for most repairs, longer for a full fan replacement. Pictures of the system and its access let us plan the work in Chiltington before we set off.
- We ask what the fan is doing, from noise and vibration to a full stop.
- The fan is isolated and opened up so we can see inside.
- We check the motor, bearings, drive, impeller and mountings.
- You hear what’s wrong and what it will cost, with a fixed quote, before we go ahead.
- Once the work is done, we run the fan and check it’s steady and quiet.
Getting ready for the visit
- Arrange a key holder or contact on site
- Move anything stored near the system
- Allow time for equipment near the work to be turned off and cool down
Getting a quote
Every quote begins with a look at the system, from your pictures and details or, where that is not enough, a survey on site. Then we send a fixed price, before any work starts.
Advice
About our extract fan repair in Chiltington
Every fan job begins with finding the fault. A noisy fan might need cleaning, new bearings or a new belt; a dead fan can point to the motor or its controls. We explain the problem, and what it will take, before we start. We are often asked to deal with a fan running too slowly to clear the kitchen and an extract that vibrates through the ductwork, on kitchen extract fans, roof and wall fans and belts and pulleys.
Rural kitchens often have fans mounted on outside walls or roofs, exposed to the weather. Weather and grease together wear out motors and bearings.
The paperwork matters as much as the work. You get a written report with photos after each visit, listing what was done, anything we couldn’t reach and when the next visit is due. Keep it with your fire safety records so it’s to hand when an insurer or inspector asks.
- Place
- Chiltington (BN7)
- Region
- East Sussex
- Records
- Report and photos after the visit
- Quotes
- Fixed quote, typically within a working day
- Hours
- When your site is closed, plus a 24/7 line
- Phone
- 0345 646 2711
- Page updated
- 30 October 2026
Part by part
Motors and bearings
If the motor runs hot or keeps tripping, something’s wrong. It may be straining against blocked filters or ducts or the motor may be near the end of its life.
Roof and wall-mounted fans
Fans are often mounted on roofs or external walls. How easy the fan is to reach shapes the job, so we ask about it early.
What your team can do, and what needs us
Good housekeeping makes our visits easier, not unnecessary. Regular in-house cleaning slows the build-up, but hidden parts of the system still need specialist attention.
Logging matters as much as cleaning. A dated log of in-house cleaning and checks shows an inspector that the system is looked after between visits, alongside our reports.
Multi-site and managed buildings
For anyone managing more than one site, we can schedule visits across all of them on one quote. Each site gets its own report and photos, so each one has its own record.
Landlords, managing agents and facilities managers book us, not only the businesses that use the systems. Where a system serves more than one tenant, such as a shared riser, it helps to agree who arranges the work, and we can quote for the whole system.
Chiltington questions
Do you cover Chiltington for emergency fan repairs?
Our emergency line runs 24/7, and Chiltington is within the area we cover. Call 0345 646 2711 and tell us what the fan is doing, or not doing. Tell us where the fan is and how to reach it.
Will you come out to Chiltington?
Yes. Villages and rural sites across the South East are part of our work, Chiltington included. Photos of the system and directions to the site help us plan the visit.
Is repair an option before replacing the whole fan?
Repair is always our starting point. If the fan is past saving, a replacement may be more sensible and we’ll tell you the reasons.
What do you do to protect the area?
Floors and surfaces near the work are sheeted before any work starts, and anything we remove is contained. Before we leave, we tidy up and clean down.
How much time does a fan repair need?
Most fan jobs take a few hours on site, depending on the fault and the access to the fan including running the fan afterwards. We will fit it around the kitchen’s hours wherever we can.
Do you look at the system first?
Yes, every time. Diagnosis comes before treatment: the survey shows what needs doing and what access we need and the fixed quote is built on it.
Do we lose a day’s trading?
Not usually. Out-of-hours visits keep the disruption down. Bigger sites can be done in stages to keep things running.
How much notice do you need?
That depends on the slot you want and the size of the job. Tell us your preferred dates when you ask for a quote, and for anything urgent, ring our 24/7 emergency line.
What affects the cost of extract fan repair
A fixed price needs a few facts first. We look at:
- Whether we need access equipment or extra panels
- Where the site is and how we reach it
- What state the system is in
- Site requirements such as sign-in and permits
Leaving it longer rarely makes the work cheaper. Build-up, wear and faults tend to get worse, not better, which can make the next visit longer. If you are unsure, phone us on 0345 646 2711 or send us an email for straight advice and a fixed quote.
Helping us quote
You don’t need the technical terms. It helps if you can send:
- The paperwork from the last visit, if you have it
- The site address and the type of premises
- Any access panels or hatches you can see
- When the site is open and when it’s quiet
For a fixed quote, call 0345 646 2711 or drop us a line and tell us the type of site, your opening hours and roughly what the system looks like. Photos and the last report, if you have one, make the quote quicker. You’ll typically have a quote within one working day.
What extract fan repair looks like in Chiltington
In Chiltington, food businesses are inspected by environmental health officers from Lewes council. Under food hygiene rules, a kitchen needs suitable and sufficient ventilation. That’s one more reason not to keep cooking with a broken fan. Chiltington is about 40 miles from central London, well within the area we cover across London and the South East. We work evenings, overnight and at weekends, so the visit fits around the site.
If you look after a church or hall kitchen near The Parish Church, or anywhere in Chiltington, test the extract fan before a big event rather than on the day.
Chiltington is about 3 miles north-west of Lewes, in East Sussex. From the centre of Chiltington to the outskirts, we cover extract fan repair for every kind of premises, from a single unit to a large public building. We cover 289 places across East Sussex, from busy centres to quieter spots. We also work in Brighton, about 7 miles from Chiltington.
We work across BN7 for extract fan repair and the streets around it. Neighbouring places we cover for extract fan repair include East Chiltington (1 mile west), Cooksbridge (1 mile south-east), South Chailey (1 mile north), Plumpton (2 miles south-west) and Plumpton Green (2 miles north-west). Within a short drive, we also cover Seaford (12 miles south-east), Lewes (3 miles south-east), Hailsham (13 miles east), Crowborough (12 miles north-east), Uckfield (7 miles north-east) and Newhaven (9 miles south).
Near you in Chiltington
The closest station to Chiltington is Cooksbridge station, roughly 1.3 miles south-east of the centre. Nearby you will also find Lewes Castle (3.5 miles south-east) and Ditchling Museum of Art + Craft (3.9 miles west). Not far away are Blackcap and Malling Down.
What we’re called out for in Chiltington
Fans everywhere, Chiltington included, live in a hard environment: hot, greasy, damp air for hours on end. Moisture can rust housings and fixings and eventually any fan simply wears out.
Any of these means the system needs a check-up:
- A worn or slipping fan belt
- A fan rattling in its housing
- Vibration spreading from the fan into the ducts
- A motor that trips out or overheats
For school kitchens, at schools like Chailey School for example, a planned fan repair in the holidays avoids losing lunches in term time.
What your quote should include
- What paperwork you get at the end
- Their accreditations, such as BESCA Vent Hygiene Elite, CHAS or SafeContractor
- Exactly which parts of the system are covered
- Proof of insurance
Leave it or put it right?
A struggling motor runs hotter and works harder. That shortens its life and a burnt-out motor is a bigger job than a worn belt. Catching it early keeps the repair small. Somewhere as small as Chiltington, losing a kitchen or building to a fault is felt by everyone who uses it.
Several systems or sites on one quote can make for a more efficient booking. Tell us about everything you’d like looked at, and you’ll get one fixed quote.
What you get with us
- Fixed quotes, typically within one working day
- Full insurance on every job
- Every job surveyed first
- One contact for all your sites in London and the South East