Kent · Extract fan repair and replacement
Extract fan repair and replacement in Ash, Kent
Extract fan repair for Ash and the surrounding area: diagnosis first, then a fixed quote, the work and a report with photos. Call for a fixed quote.
- A fan that whines, hums or grinds
- A worn or slipping fan belt
- A failed fan that needs a replacement
How the visit works
A visit follows the same order every time: sheeting and protection first, make the system safe, do the work, tidy up and hand over the paperwork. The visit itself takes a few hours on site, depending on the fault and the access to the fan. For a place like Ash, we load the van from the survey notes so the work can be done in one visit where possible.
- You describe the fault and we arrange a visit.
- We isolate the fan before touching it.
- We diagnose the fault, checking the controls as well as the fan.
- A fixed quote for the repair or replacement follows.
- We fix the fault and run the fan to check it.
Getting ready for the visit
- Dig out any earlier paperwork for the system
- Let us know how we reach the system, including roofs, risers and plant rooms
- Let us know about permits to work or site inductions
Getting a quote
Here’s what helps us quote: the address, the type of site and when it’s open, pictures of the system and the last certificate or report, if there is one. Once you have those, call us on 0345 646 2711, or email photos.
Advice
Extract fan repair in Ash
Extract fan repair starts with a diagnosis. A noisy fan might need cleaning, new bearings or a new belt, while a fan that won’t start may have a motor or control fault. We explain the problem, and what it will take, before any work starts. If you have a fan that won’t start at all and an extract fan that rattles or knocks, we can put it right.
Around a place like Ash, a pub, café or care home kitchen with a failed fan cannot carry on cooking as normal. Our 24/7 emergency line is there for exactly that.
For insurers and inspectors, the record counts. So every job comes with a written report and pictures, plus a TR19® certificate through the BESCA VHE portal where the work is a TR19® Grease clean.
- Location
- Ash (CT3)
- Region
- Kent
- Reporting
- Photo report after every visit
- Price
- A fixed quote up front
- Working hours
- Out of hours as standard, 24/7 emergency line
- Telephone
- 0345 646 2711
- Last updated
- 30 October 2026
Places near Ash
Also in Ash
What a clean won’t put right
To be straight with you, there are a few things this work will not fix:
- A greasy canopy and duct that a fan repair won’t touch
- Odour complaints that need filtration rather than a fan repair
- Gas interlock faults that a Gas Safe registered engineer must deal with
If in doubt, phone us on 0345 646 2711 or use the quote form and we’ll say what we think before you book.
Where we work
- Fan housings
- Fan motors
- Bearings
- Belts and pulleys
- Kitchen extract fans
- Roof and wall fans
What your team can do, and what needs us
Your own staff can handle the daily basics: wiping canopies, washing grease filters and recording it in a log. What they can’t safely do is clean inside the ductwork, the fan or the risers, and that’s where we come in.
Staff cleaning doesn’t replace a specialist visit; it supports it. Regular in-house cleaning slows the build-up, but hidden parts of the system still need specialist attention.
Landlords, agents and facilities managers
If you look after several sites, we can schedule visits across all of them on one quote. Each site gets its own report and pictures, so records stay tidy.
We work for landlords, managing agents and facilities managers as well as the people running the site. Shared systems, like a riser serving several units, need a clear agreement on who books the work, and we can quote for the whole system.
Looking after it afterwards
Once we have finished, these simple steps help:
- Write down when the fan misbehaves
- Clean or change filters on schedule
- Never run the extract with filters missing
- Tell us about a new rattle or whine straight away
We run the fan and check it’s steady before we go. You’ll hear what we found and what we did, and anything else we noticed is pointed out.
The fan is part of every full TR19 clean. Keeping grease off the impeller is one of the simplest ways to protect it and that means less wear.
What we are called out for in Ash
Some grease always slips past the filters and reaches the fan. Deposits gather on the blades, never quite evenly, so the fan runs out of balance and starts to vibrate and rattle.
Look out for these warning signs:
- Poor airflow at the canopy
- An old fan that needs replacing
- An extract fan that has stopped working
- A knocking noise from the extract fan
For school kitchens, at schools like Ash Cartwright and Kelsey Church of England Primary School for example, a planned fan repair in the holidays avoids losing lunches in term time.
What your quote should include
- Proof of accreditation you can verify
- Proof of insurance
- Whether inaccessible sections are listed on the report
- What’s included in the scope, part by part
What happens if it’s left?
A struggling motor runs hotter and works harder. That shortens its life, and when it finally fails, it may take other parts with it. Early attention keeps the cost and disruption down. It’s easy to lose track of when the work was last done on a quieter site.
You will not find a price list here, because each job is priced on what it involves. For a fixed quote, call 0345 646 2711 or use the quote form, and we’ll talk you through it.
Why us?
- Every job surveyed first
- Full insurance on every job
- Ventilation hygiene specialists since 2009
- Member of BESCA Vent Hygiene Elite, cleaning to BESA TR19® Grease
Take a look at what affects the cost and our accreditations.
Common questions in Ash
Who do I call if an extract fan fails in Ash?
Extract fan emergencies in Ash are covered around the clock. Call 0345 646 2711 and tell us what the fan is doing, or not doing. Let us know whether the fan is silent, noisy or tripping the power.
Do you work in villages like Ash?
Yes. Villages and rural sites across the South East are part of our work, Ash included. Photos of the system and directions to the site help us plan the visit.
Do you replace extract fans as well as repair them?
We do. A replacement is matched to the system it’s going into, and you get a fixed quote first.
Do you survey before quoting?
Yes, always. We diagnose before we treat: the survey tells us what the system needs and how to reach it, and the quote is based on that.
Will I get paperwork for my records?
Yes, always. The report is dated and includes pictures, and TR19® Grease cleans come with a certificate through the BESCA VHE portal. File it with your fire safety records.
Is repair an option before replacing the whole fan?
That depends on what we find. We diagnose first and tell you whether a repair is realistic and quote a fixed price for the option you choose.
What happens to the waste?
We take it away at the end of the visit. During the work, it’s contained so the area stays clean.
Should the fan be cleaned as well as repaired?
A repair deals with the fan, not the grease in the rest of the system. If there’s grease on the fan, a full TR19® clean is worth booking and we can plan the two together.
When a fan fails in Ash
Kitchens in Ash get their food hygiene inspections from Dover council. A kitchen with no working extract can fall short of the suitable and sufficient ventilation food hygiene rules expect. Getting the fan running again is the priority.
Occasional-use kitchens, such as a hall kitchen near Church of St Nicholas or elsewhere in Ash, are where a stiff or seized fan can turn up.
Ash is about 7 miles north-west of Deal, in Kent. From the centre of Ash to the outskirts, we cover extract fan repair for every kind of premises, from a single unit to a large public building. Across Kent, we cover 922 places, and Ash is one of them. For sites nearby, see our Maidstone page, about 33 miles away.
Every address in CT3 is within our area for extract fan repair, from busy streets to back roads. Local streets include The Street, Goodban Square and Chilton Place, all of which we cover for extract fan repair. Close by, we work in Guilton (1 mile west), Weddington (1 mile north-east), Durlock (1 mile west), Cop Street (1 mile north) and Coombe (1 mile south-east). Within a short drive, we also cover Canterbury (9 miles west), Margate (8 miles north-east), Dover (10 miles south), Folkestone (14 miles south), Ramsgate (7 miles north-east) and Broadstairs (9 miles north-east).
Near you in Ash
Around Ash, our work takes us to kitchens and buildings near The Chequer Inn and the streets around them. For rail, the closest station is Sandwich station, about 2.8 miles east of the centre. A little further out are White Mill (2.1 miles east). Green spaces nearby include Monk's Wall nature reserve.