Surrey · TR19 inspections and grease testing
TR19 Inspection in Langley Vale
TR19 inspection in Langley Vale from ventilation hygiene specialists trading since 2009. Evenings, overnight and weekends, plus a 24/7 emergency line.
- Checking the result of a recent clean
- Uncertainty over how often to clean
- Ductwork where grease may be over the TR19 limits
How we handle TR19 inspection in Langley Vale
A pre-clean survey is the diagnosis, and the clean is the treatment. We look at the system, take grease readings and photograph what we find, so the clean can be planned properly. If you’re dealing with cleaning intervals that may not suit the kitchen and pre-clean surveys before a first TR19 clean, we can put it right, from access surveys, post-clean checks and wet film thickness tests onwards.
Rural kitchens often have long, low duct runs through a roof space or along an outside wall, where grease settles in the flat sections. Access, parking and timings are agreed before the day.
Our accreditations include CHAS, SafeContractor and ISO 9001, and we’re fully insured. On top of that, we are a BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease, trading since 2009.
- Where
- Langley Vale (KT18)
- Wider area
- Surrey
- Records
- TR19® certificate and photo report
- Price
- A fixed price before we start
- Hours
- After hours by arrangement; emergencies any time
- Telephone
- 0345 646 2711
- Page updated
- 30 October 2026
TR19 inspection in Langley Vale: the local picture
The Food Standards Agency lists about 3 pubs, bars and clubs as registered food businesses within roughly a mile and a half of the centre of Langley Vale. Where they serve hot food, their kitchen extracts need cleaning to TR19® like any restaurant’s. Fire safety in Langley Vale falls to Surrey Fire and Rescue Service. In most workplaces, including commercial kitchens, it’s the fire and rescue authority that enforces the Fire Safety Order. In Langley Vale, food businesses are inspected by environmental health officers from Epsom and Ewell council. Extraction counts as kitchen equipment, so its condition can come up on the day. Our report lists what was cleaned and when, which is useful to have ready.
If you run catering at a historic house or estate in the area (Fitznells Manor is about 3.2 miles north), event kitchens in older buildings often have awkward duct runs that need planning. Bursars and site managers at schools such as The Vale Primary School tend to book extract cleaning for when the kitchen is empty.
Langley Vale is about 2 miles east of Ashtead, in Surrey. Sites in Langley Vale get the same service as everywhere we cover: a survey first, a fixed quote, work timed around your hours and a report with pictures. Langley Vale is one of 395 towns, villages and districts in Surrey we cover for TR19 inspection. Our Guildford page covers sites nearby, about 14 miles away.
Postcode districts we cover here for TR19 inspection: KT18. Streets in the area include Grosvenor Road, Harding Road and Rosebery Road, all of which we cover for TR19 inspection. Nearby, we also carry out TR19 inspection in Tattenham Corner (1 mile east), Great Burgh (1 mile east), Epsom Downs (1 mile north-east), Burgh Heath (2 miles east) and Epsom (2 miles north). Further out, we also cover Guildford (14 miles west), Woking (13 miles west), Horley (10 miles south-east), Redhill (6 miles south-east), Ewell (3 miles north) and Egham (15 miles north-west).
Around Langley Vale
Around Langley Vale, our work takes us to kitchens and buildings near Ashtead Park, Derby Arms and Rosebery School, among other places. Langley Vale’s nearest station is Tattenham Corner station, about 1 mile east. A little further out are Headley Court (1.1 miles south-west) and Walton on the Hill (1.8 miles south). The countryside around Langley Vale includes Cuddington Meadows and Colley Hill.
Why it’s worth doing now in Langley Vale
Post-clean verification shows whether the system was left the way the certificate says, while there’s still time to put anything right. Somewhere as small as Langley Vale, losing a kitchen or building to a fault is felt by everyone who uses it.
What you pay depends on the size of the system, the condition it’s in and how easy it is to reach. We give you a fixed price before work begins, so there are no surprises.
Why Langley Vale businesses choose us
- We’re fully insured
- A written report with photos after every visit
- BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease
- Out-of-hours work and a 24/7 emergency line
Take a look at how cleaning jobs are priced and how to check a contractor.
Keeping the system healthy
Results last longer with the right care. We suggest:
- Keep access panels clear and unpainted
- Clean grease off the canopy between professional cleans
- Flag changes in how much frying the kitchen does
- Flag oily drips near the extract
If any reading is 500 microns or more, the report flags it for immediate spot cleaning, and we can arrange it.
Fit access panels where the survey finds sections can’t be reached, so grease isn’t left building in hidden parts.
Langley Vale questions
Do you do school kitchen extract cleaning in Langley Vale in the summer holidays?
Yes, holiday work suits schools best. The FSA’s register shows about 3 schools and colleges with food registrations within roughly a mile and a half of Langley Vale. Booking early in the term gives the best choice of holiday dates.
Can you get to a site in Langley Vale?
Yes, Langley Vale is part of our area, however small the site. Let us know about access, parking and anything unusual about getting there when you book.
What is a WFTT or DTT grease test?
The Wet Film Thickness Test (WFTT) and Deposit Thickness Test (DTT) measure how thick the grease is at a given point. We take readings at set points from canopy to fan.
What accreditations do you have?
BESCA Vent Hygiene Elite membership, cleaning to BESA TR19® Grease, plus CHAS, SafeContractor and ISO 9001. We’re fully insured and have been trading since 2009.
Can you price the work without visiting?
Normally, yes. Send a few wide photos plus close-ups of panels, filters or grilles, and a fixed quote usually follows within one working day. Some sites still need a visit, and we will say so.
How long does grease testing take?
As a guide, it takes a couple of hours for a typical kitchen extract system. The size of the system and the access make the difference.
When should we have our next grease test?
Each report recommends when to test and clean next, based on the readings and how the kitchen is used. The interval should come from a competent person’s risk assessment backed by grease measurement.
What should I send you?
A short description and a few photos, with the address and opening hours. If we need more, we’ll ask.
How the visit works
Every visit runs to the same pattern: sheeting and protection first, isolate whatever needs isolating, carry out the TR19 inspection, tidy up and hand over the paperwork. The visit itself takes a couple of hours for a typical kitchen extract system. A quick note on how to find the site and where to park makes a visit to Langley Vale run smoothly.
- After the clean, we arrange a time to check the system.
- The same access points are opened up.
- We repeat the WFTT or DTT readings.
- We photograph each area to record how it was left.
- The results are reported, with anything missed flagged.
Preparing for the visit
- Tell us about site rules, permits or sign-in
- Tell us about access, such as roof hatches, plant rooms, ceilings or locked areas
- Let us know when the site is closed or quiet
How to get a quote
To get a fixed quote, give us a ring on 0345 646 2711, or email photos with the site type, your trading hours and a short description of the system. A few pictures and your last certificate or report help a lot. We typically come back within one working day.
Advice
Part by part
Vertical risers
Risers can be hard to get into. The survey shows exactly what access there is.
Horizontal duct runs
Flat duct runs collect grease along their base. We test at points along the run through access panels.
Towns and villages near Langley Vale
Also in Langley Vale
How we price TR19 inspection
We do not publish a price list, because no two systems are the same. What we look at:
- The condition we find in the survey
- Whether several sites go on one quote
- Whether we need access equipment or extra panels
- One-off work versus a regular cycle
Leaving it longer rarely makes the work cheaper. Build-up, wear and faults tend to get worse, not better, and a neglected system can mean more work. If you are unsure, give us a ring on 0345 646 2711, or send details by email and we’ll give you an honest view and a fixed quote.
Asking for a quote
What to send for a quote:
- Photos showing the whole system and its surroundings
- When the site is open and when it’s quiet
- Where the site is and what kind of site it is
- The roof, plant room or outside wall the system runs to
There’s no standard price list, because every site is different. Instead, we look at your site first, from pictures or a survey, then send a fixed quote. To start, give us a ring on 0345 646 2711 or use the quote form.
What staff can safely do
For ventilation and air handling systems, in-house care is mostly about checks: keeping grilles clear, noting unusual noise or smells and logging filter changes. The inside of ducts and units needs a specialist.
Good housekeeping makes our visits easier, not unnecessary. Regular in-house cleaning slows the build-up, but the parts you cannot see still need a specialist at the right interval.
Common problems we fix in Langley Vale
Some parts of a system are hard to reach, and grease can be missed there clean after clean. A survey finds the sections that can’t be reached, so panels can be fitted.
These are the problems we see most often:
- Sites with gaps in their extract records
- Surveys needed before quoting a full clean
- Uncertainty over how often to clean
- Heavy grease suspected in the plenum or ducts
A hall kitchen that only cooks for events, whether near St Stephen On The Downs or elsewhere in Langley Vale, still needs its extract cleaned, just less often.
What your quote should include
- If they look at the system before pricing
- How they set the interval to the next visit
- What records you’ll receive afterwards
- Whether they’re fully insured