Kent · Extract fan repair and replacement
Extract Fan Repair in Stone Hill
Need extract fan repair in Stone Hill? We survey first, send you a fixed quote and work around your opening hours, then sign off with a report and photos.
- A humming noise from the fan motor
- An extract that vibrates through the ductwork
- An old fan that needs replacing
Between visits
No system stays clean for ever, but care slows the build-up. A few tips:
- Keep the fan on a planned cleaning cycle
- Make sure staff know who to call if the fan fails
- Keep the area around the fan controls clear
- Never run the extract with filters missing
If the fan had grease on it, the rest of the system almost certainly does too. We can book a TR19® clean of the whole extract and you get a TR19 certificate and photo report afterwards.
The fan is part of every full TR19 clean. Keeping grease off the impeller is one of the simplest ways to protect it and that means less wear.
Extract fan repair in Stone Hill, done properly
We treat a failing fan much like a patient: listen to it, diagnose the fault, then treat it. The aim is steady, quiet extraction and a clear explanation of what was done. The work covers kitchen extract fans, belts and pulleys and fan motors, and common reasons people get in touch are a squealing belt on start-up and a failed fan that needs a replacement.
Somewhere as small as Stone Hill, a kitchen extract fan might serve a pub, a school, a care home or a hall kitchen. When one fails, the cooking stops, and emergency callout is available 24/7, villages included.
Accreditations are easy to claim and worth checking. Ours are BESCA Vent Hygiene Elite membership, cleaning to BESA TR19® Grease, plus CHAS, SafeContractor and ISO 9001, with full insurance on top.
- Where
- Stone Hill (TN25)
- Region
- Kent
- Reporting
- Photo report after each visit
- Quotes
- A fixed quote up front
- When we work
- When your site is closed, plus a 24/7 line
- Phone
- 0345 646 2711
- Checked
- 30 October 2026
How the visit works
The first job on site is protection: floors, worktops and anything near the work are covered. After that, the system is made safe and the work begins. The work on site takes anything from an hour or two to a full visit, depending on the fault, and we clear up before we go. Rural roads and tight entrances are worth telling us about before a visit to Stone Hill.
- We start with the symptoms, such as rattling, humming, slow running or a fan that won’t start.
- With the fan safely isolated, we open it up for a proper look.
- Each part is checked in turn: motor, bearings, drive, impeller and fixings.
- You hear what’s wrong and what it will cost, with a fixed quote, before we go ahead.
- We fix or replace the fan, then test it running before we leave.
Before we arrive
- Let us know when the site is closed or quiet
- Allow time for equipment near the work to be turned off and cool down
- Move anything stored near the system
How to get a quote
Some systems can be priced from photos; others need a survey. Larger sites, and anything hidden behind walls, ceilings or floors, are normally surveyed first. Either way, the quote is fixed before any work is booked.
Read more
What extract fan repair cannot fix
To be straight with you, some problems need a different fix:
- An extract system that was undersized from the start
- Grease build-up in the rest of the extract system
- Cooking smells reaching neighbours, which may need odour control
If you are not sure, just give us a ring on 0345 646 2711 or email us and we will give you a straight answer before you book.
What the work covers
- Fan motors
- Roof and wall fans
- Fan housings
- Belts and pulleys
- Kitchen extract fans
- Bearings
When a fan fails in Stone Hill
Environmental health officers from Folkestone and Hythe council inspect food businesses in Stone Hill. Food hygiene rules expect food premises to have suitable and sufficient ventilation. That is one more reason not to keep cooking with a broken fan. Stone Hill is about 54 miles from central London, well within the area we cover across London and the South East. We work evenings, overnight and at weekends, so the visit fits around the site.
Occasional-use kitchens, such as a hall kitchen near Church of St Mary or elsewhere in Stone Hill, are where a stiff or seized fan can turn up.
Stone Hill is about 5 miles north-west of Hythe, in Kent. We provide extract fan repair for businesses, landlords and public buildings in Stone Hill and the rest of Kent. Across Kent, we cover 922 places, and Stone Hill is one of them. You can also see our page for Maidstone, about 23 miles away.
Extract fan repair in TN25 follows the same survey, fixed quote and written report as everywhere else we cover. Extract fan repair is available to premises on Stone Hill, Southenay Lane and Cooper's Lane and the roads around them. Other places close to Stone Hill include Lilyvale (1 mile north-west), Brabourne Lees (1 mile north-west), Smeeth (1 mile north-west), Ridgeway (1 mile north-west) and Bircholt Forstal (2 miles north). Within a short drive, we also cover Ashford (6 miles west), Canterbury (12 miles north), Dover (14 miles east), Folkestone (8 miles east), Faversham (15 miles north) and Hythe (5 miles south-east).
Around Stone Hill
Stone Hill’s nearest station is Westenhanger station, roughly 2.4 miles south-east of the centre. Well-known places in the area include Lympne Castle (3.1 miles south-east) and William Harvey Hospital (3.8 miles north-west). Green spaces nearby include Hatch Park and Tolsford Hill.
What the work involves, part by part
Motors and bearings
Motors and bearings take the most strain in a kitchen extract fan. Hot, greasy air and long days wear them down.
Impellers and housings
The fan housing collects grease too. Both are inspected, and cleaning can form part of the repair.
Managing agents and facilities teams in Stone Hill
Landlords, managing agents and facilities managers book us, not only the businesses that use the systems. Where a system serves more than one tenant, such as a shared riser, it helps to agree who arranges the work, and we’re happy to quote for all of it.
When the building owner and the occupier are different, the lease normally sets out who maintains what. We’re happy to deal with either side and send the paperwork to whoever needs it.
Places near Stone Hill
Also in Stone Hill
FAQs for Stone Hill
Is Stone Hill within the area you cover?
Yes. Villages and rural sites across the South East are part of our work, Stone Hill included. The journey is planned ahead, so a few details about the route help.
Do you work overnight in Stone Hill?
Yes, evening, overnight and weekend work is normal for us. Your customers, staff or residents in Stone Hill needn’t be disturbed. Just give us a ring on 0345 646 2711 or email us with your opening times and we will plan around them.
Is repair an option before replacing the whole fan?
Repair is always our starting point. If the fan is past saving, a replacement may be more sensible and we will tell you the reasons.
Do you look at the system first?
Yes. We always survey first, from your pictures and details, or with a visit where necessary. A fixed quote follows.
Which kinds of sites do you work on?
Commercial premises of every kind: from restaurants, pubs and hotels to schools, hospitals, care homes, offices, shops and food production sites. Work is timed around how each site runs.
Will you tell us when the next visit is due?
Yes. The report recommends when the next visit should be, based on use and what we found.
Does the law say we must follow TR19?
No. The law sets the duty, and TR19® is the recognised benchmark for meeting it. Under the Regulatory Reform (Fire Safety) Order 2005, the responsible person has to manage fire risk, and without records, many insurers may refuse or reduce a claim.
Do we lose a day’s trading?
Not usually. We work when the area is out of use, such as evenings, overnight, early mornings or weekends, so you keep your normal hours.
What your team can do, and what needs us
When your team notices a problem between visits, such as dripping grease, a noisy fan, a smell or a filter that won’t come clean, it’s best reported rather than tackled in-house. We can diagnose it and quote.
Staff cleaning and specialist work are not the same thing. A daily filter wipe and a weekly filter wash keep grease down at the front of the system, but grease that has passed the filters is out of reach. Reaching it takes a specialist with the right equipment.
Do you need extract fan repair in Stone Hill?
Over the years, mountings loosen and rubber mounts break down. The fan’s movement then travels into the ductwork and structure, which is where knocking and rattling often come from.
Clients normally contact us when they notice something like this:
- A knocking noise from the extract fan
- An extract that vibrates through the ductwork
- A fan running too slowly to clear the kitchen
- A fan that keeps cutting out
If you run a school kitchen, at a school such as Sellindge Primary School or nearby, a fan that’s getting noisy is best repaired in the holidays before it fails in term.
What to look for in a quote
- Whether the quote is based on a survey or pictures
- What insurance they carry
- Whether the figure could change on the day
- How VAT is shown on the quote