Kent · Extract fan repair and replacement
Extract fan repair and replacement in Pett Bottom, Kent
Need extract fan repair in Pett Bottom? We diagnose first, fix the price and book the work around your hours, then sign off with a report and pictures.
- A fan worn beyond sensible repair
- An extract that vibrates through the ductwork
- A fan that whines, hums or grinds
Extract fan repair in Pett Bottom, done properly
Across Pett Bottom, we deal with fan faults of every kind, from a squeal at start-up to a fan that will not run at all. The fault is diagnosed, quoted at a fixed price and put right, or the fan is replaced if repair doesn’t make sense. We are often asked to deal with a humming noise from the fan motor and a fan worn beyond sensible repair, on fan motors, bearings and kitchen extract fans.
A callout to a small place like Pett Bottom goes better when we know what we’re looking at: pictures of the fan, its rating plate and how to reach it all help.
Good records are part of the job. You get a written report with photos after every visit, listing what was done, anything we couldn’t reach and when the next visit is due. Keep it with your fire safety records so it’s to hand when an insurer or inspector asks.
- Where
- Pett Bottom (CT4)
- Wider area
- Kent
- Paperwork
- Report and photos after the visit
- Quotes
- Fixed quote, normally within a working day
- Working hours
- Evenings, overnight and weekends; 24/7 emergencies
- Phone
- 0345 646 2711
- Page updated
- 30 October 2026
Honest limits
An honest diagnosis matters more to us than a booking, so here’s what this work can’t put right:
- Problems with the gas supply or its interlock valve
- Odour complaints that need filtration rather than a fan repair
- Grease build-up in the rest of the extract system
If in doubt, call 0345 646 2711, or email photos and we will say what we think before booking.
What the work covers
- Fan motors
- Belts and pulleys
- Fan housings
- Roof and wall fans
- Bearings
- Kitchen extract fans
Pett Bottom questions
Can you work in Pett Bottom outside opening hours?
Yes, we can come after you close and finish before you open. The work in Pett Bottom can fit around your hours. Just call 0345 646 2711 or drop us a line with your opening times and we’ll plan around them.
Is Pett Bottom within the area you cover?
Yes, Pett Bottom is part of our area, however small the site. Photos of the system and directions to the site help us plan the visit.
How do you protect the area?
By covering it before any work starts. The work is kept contained and clean down when we finish.
Can you come out in an emergency?
Yes, day and night, every day of the year. Office hours are Monday to Friday, 8am to 6pm, with the emergency line covering every other hour.
What does TR19 mean?
TR19® is BESA’s specification for ventilation hygiene. TR19® Grease, a standalone specification since 2019, covers grease in kitchen extract systems, while TR19® Air covers other supply and extract ductwork.
Is TR19 a legal requirement?
No. The law sets the duty, and TR19® is the recognised benchmark for meeting it. Under the Regulatory Reform (Fire Safety) Order 2005, the responsible person has to manage fire risk, and without records, many insurers may refuse or reduce a claim.
Where does the waste go?
It’s contained and taken away. We collect grease, debris and waste water as we go, so it doesn’t spread.
What happens if you can’t reach some of it?
Anything we cannot reach goes on the report, with photos where possible, and we tell you what would make it reachable, such as extra access panels in ductwork.
How the visit works
A visit follows the same order every time: sheeting and protection first, isolate whatever needs isolating, do the work, clear away and hand over the paperwork. The visit itself takes an hour or two to diagnose, then longer if parts or a new fan are needed. Somewhere like Pett Bottom, lanes, gates and parking are worth mentioning in advance.
- You describe the fault and we arrange a visit.
- We isolate the fan before touching it.
- We diagnose the fault, checking the controls as well as the fan.
- You get a fixed price for putting it right.
- The work is done and the fan is tested running.
Before we arrive
- Make sure equipment near the work can be switched off and left to cool
- Let us know how we reach the system, including roofs, risers and plant rooms
- Mention any sign-in, permit or induction we need
Getting a quote
Getting a quote does not take long. Send a few details and photos, and we usually reply with a fixed quote within one working day. Where a survey is needed, we arrange a time that suits the site.
Read more
Extract fans in Pett Bottom
At about 55 miles from central London, Pett Bottom sits well inside the area we cover. Evening, overnight and weekend visits are all possible. It’s Canterbury City council that sends environmental health officers to food businesses in Pett Bottom. Food premises are expected to have suitable and sufficient ventilation under food hygiene rules. So a failed fan is worth fixing before the next service, not the next month.
If you run a church or community hall kitchen, near Church of St Mary or elsewhere in Pett Bottom, an extract fan that rarely runs can seize or fail when it’s needed. If you manage a school such as Simon Langton Grammar School for Boys and the kitchen fan is getting louder, the next break is the time to deal with it.
Pett Bottom is about 4 miles south of Canterbury, in Kent. Whatever kind of site you run in Pett Bottom, extract fan repair is something we can help with. We can work out of hours so the site keeps running. Across Kent, we cover 922 places, and Pett Bottom is one of them. For sites nearby, see our Maidstone page, about 25 miles away.
We work across the CT4 postcode area for extract fan repair and the streets around it. That includes premises on Pett Bottom Road and School Lane and nearby roads. We also cover the places around Pett Bottom: Lower Hardres (1 mile north-west), Upper Hardres (1 mile south-west), Street End (1 mile north-west), Lynsore Bottom (1 mile south) and Nackington (2 miles north). Within a short drive, we also cover Ashford (12 miles south-west), Canterbury (4 miles north), Dover (11 miles south-east), Folkestone (10 miles south), Whitstable (9 miles north) and Deal (13 miles east).
Around Pett Bottom
Locally, jobs take us to businesses close to The Duck pub, among other places. For rail, the closest station is Bekesbourne station, about 3 miles north-east. Well-known places in the area include Canterbury Castle (3.4 miles north) and Rupert Bear Museum (3.5 miles north).
Different parts, different methods
Motors and bearings
The motor and its bearings work hardest. Heat, grease and long running hours all wear them.
Impellers and housings
Grease settles inside the fan housing as well as on the blades. Both are inspected and cleaning may be part of the fix.
Landlords, agents and facilities managers
If you look after several sites, we can plan visits across the whole estate and price them together. Every building has its own written report, so each one has its own record.
Landlords, managing agents and facilities managers book us, not only the businesses that use the systems. Where a system serves more than one tenant, such as a shared riser, it helps to agree who arranges the work, and we are happy to quote for all of it.
What affects the quote in Pett Bottom
Before we fix a price, we need to know a few things. We check:
- How big the system is
- The number of sites or systems
- Site requirements such as sign-in and permits
- The condition we find in the survey
Whatever the type of site, the quote works the same way: the size of the job, access, condition and working hours. Ask for a fixed quote and we’ll go through it with you.
Helping us quote
We can often survey from photos. The most useful are:
- Where the plant sits or the system leaves the building, such as a roof or outside wall
- The site address and the type of premises
- The times we could work without disrupting the site
- Wide photos of the system and the area around it
Want a quote for extract fan repair? Please call us on 0345 646 2711 or send us an email and tell us about the site. We will explain what we’d do and send a fixed quote before you commit to anything.
Why it’s worth doing now in Pett Bottom
It can be tempting to turn the fan down to quieten it. It hides the symptom and weakens the extract, and the fault carries on developing. A proper diagnosis in Pett Bottom gets to the real cause. A planned visit to Pett Bottom is easier to arrange than an emergency callout.
Combining work into one visit or one programme often makes better use of the time. Tell us about everything you’d like looked at and we will price it together.
What you get with us
- CHAS, SafeContractor and ISO 9001
- We are fully insured
- A BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease
- Each visit written up, with pictures
See our cost guide and our accreditations.
Between visits
Aftercare is simple, and it helps at the next visit:
- Note when the fan trips or cuts out
- Book regular TR19 cleaning, which includes the fan
- Avoid lowering the speed to quieten a fault
- Keep the area around the fan controls clear
Keep an ear on the fan after the repair. If anything changes, let us know, so it can be looked at before it grows.
A fan that is starting to make noise is giving you a warning. Getting it checked now means a planned repair instead of a breakdown at the worst moment.