Isle of Wight · Extract fan repair and replacement
Extract Fan Repair in Appley
Extract fan repair for Appley, from a team that has been trading since 2009. Evenings, overnight and weekends, plus a 24/7 emergency line.
- A motor that trips out or overheats
- Vibration spreading from the fan into the ducts
- A worn or slipping fan belt
Extract fan repair for kitchens and businesses in Appley
A faulty fan does not always mean a new one. Sometimes cleaning the impeller or renewing worn parts is enough, and that is what we will recommend. Where the motor has burnt out or the unit is past saving, a replacement suited to the system goes in. The work covers bearings, kitchen extract fans and fan housings, and common reasons people get in touch are a dead fan motor and a failed fan that needs a replacement.
For a fan repair near Appley, we plan the journey and bring what the job is likely to need, based on what you tell us about the fan.
The report is your system’s health record: dated, with pictures, and showing what was done. For TR19® Grease cleans, the certificate comes through the BESCA Vent Hygiene Elite portal and sits alongside the report.
- Place
- Appley (PO33, PO34)
- Wider area
- Isle of Wight
- Records
- Written report with pictures
- Quotes
- Fixed quote, normally within a working day
- Hours
- Overnight and weekend work, 24/7 emergency callout
- Call
- 0345 646 2711
- Last updated
- 30 October 2026
What extract fan repair can’t fix
Some problems need a different service or another trade:
- Smells from the discharge that need odour control equipment
- Problems with the electrical supply to the fan (an electrician’s job)
- Gas interlock faults that a Gas Safe registered engineer must deal with
If you are not sure, just call us on 0345 646 2711, or email photos and we will give you a straight answer before you book.
Where we work
- Bearings
- Fan motors
- Fan housings
- Belts and pulleys
- Kitchen extract fans
- Roof and wall fans
Leave it or put it right?
Vibration does damage beyond the fan. Fixings work loose and joints in the ductwork can be strained, so a small repair can grow into a bigger one. A site near Appley that has to close at short notice is hard to cover for.
Putting the work off seldom saves money. Problems in a system tend to grow, and a neglected system can mean more work. If you are not sure what’s needed, call 0345 646 2711, or email photos and we’ll give you an honest view and a fixed quote.
Why book with us
- Full insurance on every job
- CHAS and SafeContractor accredited, with ISO 9001
- One number for every site across the South East and London
- Out-of-hours work and a 24/7 emergency line
Take a look at how cleaning jobs are priced or our accreditations and certificates.
For landlords and multi-site operators
Running several sites is easier with one contractor. We cover South East England and London, so visits at different addresses can be planned together and kept to a regular schedule.
The Fire Safety Order 2005 puts the duty to manage fire risk on the responsible person, and that can be the employer, the owner, a landlord, a facilities manager or a managing agent. With shared responsibility, good records help everyone.
When a fan fails in Appley
Appley is within about 1 mile of the coast. Motor mounts, bolts and housings on outdoor fans corrode faster close to the coast. Food Standards Agency data counts about 58 restaurants, cafés and works canteens and about 23 takeaways in and around Appley, up to about a mile and a half out. Every one of them that cooks under a canopy depends on its extract fan to keep cooking. Food hygiene inspections in Appley are the job of Isle of Wight council’s environmental health team. Under food hygiene rules, a kitchen needs suitable and sufficient ventilation. So a failed fan is worth fixing before the next service, not the next month.
For a takeaway near Ryde St Johns Road station, a fan that fails on a busy evening means turning customers away, and our emergency line runs 24/7. Occasional-use kitchens, such as a hall kitchen near St John's Church or elsewhere in Appley, are where a stiff or seized fan can turn up.
Appley is about 1 mile east of Ryde, in the Isle of Wight. We provide extract fan repair for commercial premises of every kind in Appley and the rest of the Isle of Wight. Across the Isle of Wight, we cover 125 places, Appley among them. Portsmouth is in our area too, about 6 miles from Appley.
Every address in PO33 and PO34 is within our area for extract fan repair, from the main roads to the quietest streets. We cover sites on Park Road, Rink Road and Hope Road and the roads around them. Appley is on the A3055, which makes it straightforward for our technicians to reach for extract fan repair. Neighbouring places we cover for extract fan repair include Elmfield (1 mile south-west), Puckpool (1 mile east), Oakfield (1 mile south-west), Ryde (1 mile west) and Westridge (1 mile south). Larger places within reach include Newport (7 miles west), Cowes (7 miles west), Sandown (5 miles south), Shanklin (7 miles south), Ventnor (9 miles south) and East Cowes (6 miles west). For island and remote sites, a little more planning is needed, so mention it when you ask for a quote.
Local landmarks in Appley
Around Appley, our work takes us to kitchens and buildings near Ryde Academy, Ryde School with Upper Chine and Appley Manor Hotel, among other places. The nearest railway station is Ryde St Johns Road station, about 0.5 miles west of the centre. Other landmarks nearby include Gosport War Memorial Hospital (4.7 miles north) and Southsea Castle (4.4 miles north-east). The countryside around Appley includes Brading Down and Alan Hersey Nature Reserve.
When to call us in Appley
Some grease always slips past the filters and reaches the fan. It builds up on the impeller blades unevenly, so the fan runs out of balance and the noise follows.
It’s time to book a visit if you see:
- A motor that trips out or overheats
- A worn or slipping fan belt
- Poor airflow at the canopy
- A humming noise from the fan motor
If you run a school kitchen, at a school such as Oakfield Church of England Aided Primary School or nearby, a fan that is getting noisy is best repaired in the holidays before it fails in term.
What to look for in a quote
- Whether the whole system is included, or only the parts that are easy to reach
- Whether VAT is included
- Whether inaccessible sections are listed on the report
- Whether a written report and pictures are included
What the work involves, part by part
Fan controls
We check the controls as part of every diagnosis since the motor isn’t always to blame.
Impellers and housings
Grease settles inside the fan housing as well as on the blades. We check both, and cleaning can form part of the repair.
Staff cleaning versus specialist work
Some jobs should never be done in-house: entering ducts, working on fans, testing dampers and taking grease readings need training, the right equipment and safe access. Leave those to us.
Staff cleaning and specialist work are not the same thing. A daily filter wipe and a weekly filter wash keep grease down at the front of the system, but grease that has passed the filters is out of reach. That part needs specialist access and equipment.
What we do, step by step
The visit has three parts: set-up, the treatment itself and the sign-off. Getting ready means protecting surfaces and switching off what needs to be off, while signing off means the written report and photos. The middle part takes longest, and that takes an hour or two to diagnose, then longer if parts or a new fan are needed. In a smaller place like Appley, parking is rarely the issue, but tell us about gates, roof access and opening hours.
- We ask what the fan is doing, from noise and vibration to a full stop.
- Power to the fan is isolated before we open the housing.
- The impeller, bearings, belts or drive, motor and mounts are all inspected.
- You get our diagnosis and a fixed quote to repair or replace.
- Once the work is done, we run the fan and check it’s steady and quiet.
Getting ready for the visit
- Find the previous report, if there is one
- Arrange a key holder or contact on site
- Tell us about site rules, permits or sign-in
Ask for a quote
Every quote begins with a look at the system, either from photos and details you send or from a site visit. Then we send a fixed price, before any work starts.
Advice
What else we do in Appley
Appley questions
Who carries out food hygiene inspections in Appley?
The local authority for Appley is Isle of Wight council, and its environmental health team does the inspecting. If the extract fan has failed, it’s worth having the repair booked, and the details to hand, before an officer visits.
Can the work in Appley be done at night or at weekends?
Yes, evening, overnight and weekend work is normal for us. The site is handed back ready to open. When you ring 0345 646 2711, or email photos, mention when the site is quiet.
Will we have to shut during the visit?
Normally not. Out-of-hours visits keep the disruption down. Larger jobs can be phased over several visits so parts stay in use.
What do you do to protect the area?
With sheeting and covers, before anything else happens. We keep the work contained and leave the area clean.
Is it worth cleaning the extract while you’re fixing the fan?
A fan repair on its own does not include the ductwork. We’ll tell you what we see and quote for a TR19 clean if it’s needed.
Is repair an option before replacing the whole fan?
That depends on what we find. We diagnose first and tell you whether a repair is realistic and quote a fixed price for the option you choose.
Are you fully insured?
Yes. Full insurance covers our work, and we have been trading since 2009.
Is Appley in your area?
Yes. Our area takes in London and the counties of South East England, Appley included.