Essex · Extract fan repair and replacement
Extract Fan Repair in Skye Green
Extract fan repair across Skye Green and nearby, timed so the site keeps working and signed off in writing with pictures.
- A knocking noise from the extract fan
- A dead fan motor
- A motor that trips out or overheats
Extract fan repair in Skye Green, done properly
Extract fan repair starts with a diagnosis. Noise can come from grease on the impeller, worn bearings or a slipping belt; a dead fan can point to the motor or its controls. We explain the problem, and what it will take, before work begins. If you are dealing with a humming noise from the fan motor and a fan worn beyond sensible repair, we can help, from belts and pulleys, fan housings and roof and wall fans onwards.
Rural kitchens often have fans mounted on outside walls or roofs, exposed to the weather. Weather and grease together wear out motors and bearings.
The sign-off is always in writing: a dated report with photos of the work, plus a certificate through the BESCA Vent Hygiene Elite portal when the work is a TR19® Grease clean. Any parts we couldn’t reach are recorded on it too.
- Where
- Skye Green (CO5, CO6)
- Region
- Essex
- Records
- Photo report after each visit
- Price
- Fixed quote, typically within a working day
- Working hours
- After hours by arrangement; emergencies any time
- Phone
- 0345 646 2711
- Last updated
- 30 October 2026
Between visits
So the system stays in good health:
- Keep all filters fitted while cooking
- Don’t turn the fan down to hide a noise
- Make sure every filter is in place and clean
- Keep the area around the fan controls clear
We run the fan and check it’s steady before we go. You’ll hear what we found and what we did, and anything else we noticed is pointed out.
A scheduled maintenance plan keeps the whole system on a regular cycle, so the fan is looked at as part of each visit and wear is caught earlier.
How it works
A visit follows the same order every time: sheeting and protection first, isolate whatever needs isolating, do the work, tidy up and hand over the paperwork. On site, the work takes a few hours on site, depending on the fault and the access to the fan. If the van will struggle with a lane or gateway near Skye Green, let us know and we’ll plan around it.
- We ask what the fan is doing, from noise and vibration to a full stop.
- The fan is isolated and opened up so we can see inside.
- The impeller, bearings, belts or drive, motor and mounts are all inspected.
- You get our diagnosis and a fixed quote to repair or replace.
- The repair or replacement is carried out and the fan is run and checked.
Preparing for the visit
- Move anything stored near the system
- Tell us about access, such as roof hatches, plant rooms, ceilings or locked areas
- Let us know when the site is closed or quiet
Get a fixed quote
There’s no standard price list, because no two systems are the same. Instead, we look at your site first, from photos or a survey, then send a fixed quote. To get going, call 0345 646 2711, or email photos.
Advice
Nearby places to Skye Green
More services for Skye Green
How we price extract fan repair
The price is fixed before any work begins. It’s based on:
- Whether it’s a one-off visit or part of a schedule
- Whether we need access equipment or extra panels
- Site requirements such as sign-in and permits
- The size of the system
Putting the work off seldom saves money. Problems in a system tend to grow, and a neglected system can mean more work. If you’re not sure what’s needed, call 0345 646 2711 or send us an email and we’ll give you an honest view and a fixed quote.
What we need to know
We can often survey from photos. Try to include:
- Detail shots of panels, filters and grilles
- Wide pictures of the system and the area around it
- Where the site is and what kind of site it is
- The times we could work without disrupting the site
Photos are enough for some jobs, while others need a look on site. Larger sites, and anything hidden behind walls, ceilings or floors, are normally surveyed first. Either way, the quote is fixed before any work is booked.
When to call us in Skye Green
Blocked filters and greasy ducts make the fan work harder. An overworked motor overheats, trips out or eventually burns out.
These are the problems we see most often:
- A motor that trips out or overheats
- A worn or slipping fan belt
- Vibration spreading from the fan into the ducts
- A dead fan motor
For school kitchens, at schools like Honywood Community Science School for example, a planned fan repair in the holidays avoids losing lunches in term time.
What your quote should include
- What’s included in the scope, part by part
- When they can work, and whether that is outside your opening hours
- Whether the figure could change on the day
- What happens if part of the system cannot be accessed
In-house cleaning or a specialist?
Good housekeeping makes our visits easier, not unnecessary. Clean filters and tidy surfaces slow the build-up, but hidden parts of the system still need specialist attention.
If your staff spot something between visits, such as dripping grease, a noisy fan, a smell or a filter that will not come clean, it’s best reported rather than tackled in-house. We can diagnose it and quote.
When a fan fails in Skye Green
There are about 8 restaurants, cafés and works canteens and about 4 takeaways within 1.5 miles or so of the middle of Skye Green, according to the Food Standards Agency’s register. Wherever they cook under a canopy, a failed extract fan stops the kitchen. About 43 miles out from central London, Skye Green is part of the South East area we work across. A survey and a fixed quote come first, then the visit at a time that suits you. In Skye Green, food businesses are inspected by environmental health officers from Braintree council. Food premises are expected to have suitable and sufficient ventilation under food hygiene rules. So a failed fan is worth fixing before the next service, not the next month.
If you run a church or community hall kitchen, near Parish Church of All Saints or elsewhere in Skye Green, an extract fan that rarely runs can seize or fail when it’s needed.
Skye Green is about 4 miles north of Tiptree, in Essex. Anywhere in CO5, we can take on extract fan repair. Skye Green is one of 644 towns, villages and districts in Essex we cover for commercial clients. We also work in Chelmsford, about 13 miles from Skye Green.
Work in CO5 and CO6 follows the same survey, fixed quote and written report as everywhere else we cover. Extract fan repair is available to premises on Old Road and Mill Lane and the roads around them. We also cover the places around Skye Green: Surrex (1 mile north-west), Stocks Green (1 mile south), Broad Green (1 mile north-east), Little Tey (1 mile north-east) and Feering (2 miles south). Further out, we also cover Colchester (8 miles east), Chelmsford (13 miles south-west), Braintree (7 miles west), Maldon (10 miles south), Witham (6 miles south-west) and Camulodunum (7 miles east).
Around Skye Green
Locally, jobs take us to businesses close to The Queens Head pub. For rail, the closest station is Kelvedon station, about 1.9 miles south. Well-known places in the area include Laundry & Mangle Museum (2 miles west) and Birch Castle (4.6 miles east). For a walk, there’s Tiptree Heath Nature Reserve.
For landlords and multi-site operators
Under the Regulatory Reform (Fire Safety) Order 2005, the responsible person must assess and reduce fire risk, which may be the employer, owner, landlord, FM or managing agent. Where responsibility is shared, records matter even more.
Keeping records across a portfolio is half the battle. Every visit ends with a dated report and pictures, so you can show an insurer or inspector what was done at each site.
When it’s something else
Extract fan repair cannot fix everything, and we’d rather say so up front. It won’t put right:
- A system that needs redesigning rather than repairing
- A greasy canopy and duct that a fan repair will not touch
- Faults in the building’s electrical supply, which need an electrician
Not sure which it is? You can give us a ring on 0345 646 2711 or drop us a line and we’ll tell you honestly.
What we work on in Skye Green
- Belts and pulleys
- Kitchen extract fans
- Bearings
- Fan motors
- Roof and wall fans
- Fan housings
FAQs for Skye Green
Will you come out to Skye Green?
Yes, Skye Green is part of our area, however small the site. The journey is planned ahead, so a few details about the route help.
Do you work overnight in Skye Green?
Yes, we can come after you close and finish before you open. The site is handed back ready to open. Let us know the hours you are closed and we will book within them.
What will a fan repair or replacement cost?
We price each job after finding the cause. A belt and a new fan are very different jobs so the first step is a diagnosis.
Do I get a report after the visit?
Yes. It’s the record insurers and inspectors ask to see: a dated report with pictures, listing the work and any areas we couldn’t reach.
What do you do with what you remove?
It’s contained and taken away. We collect grease, debris and waste water as we go rather than letting it spread.
Does the report say when we need you again?
Yes. How often depends on use and condition and the report sets out why.
Do you offer maintenance contracts?
Yes. Regular plans can run on 3, 6 or 12-monthly cycles, to suit the system and how it’s used.
Is it worth cleaning the extract while you are fixing the fan?
The ductwork is a separate job. We’ll point out grease where we find it and quote for a TR19 clean if it’s needed.