Essex · Extract fan repair and replacement
Extract Fan Repair in Old Heath
Extract fan repair and replacement for businesses, landlords and public buildings in Old Heath. CHAS, SafeContractor and ISO 9001, and fully insured.
- A fan that keeps cutting out
- A fan worn beyond sensible repair
- A fan rattling in its housing
Old Heath: your questions answered
Do you cover Old Heath for emergency fan repairs?
We run a 24/7 emergency line for failed extract fans, and Old Heath is part of our area. Phone 0345 646 2711 and we will talk through the fault and access. A photo of the fan’s rating plate helps.
Does the sea air around Old Heath make a difference to extract fan repair?
It can. Salt air reaches Old Heath, which is within about 3 miles of the coast, and it speeds up rust. A fan housing that’s rusting near the coast can fail sooner, so it’s worth catching early.
How much notice should we give?
Earlier is better, particularly for night and weekend visits. Quotes usually come back within one working day, and emergencies are covered by our 24/7 line.
Will I get paperwork for my records?
Yes. It’s your proof that the work was done: a dated report with pictures, listing the work and any areas we couldn’t reach.
Will we have to shut during the visit?
Not normally. Visits are timed for when the area is closed, such as overnight or at a weekend, so the site can carry on as normal.
What will a fan repair or replacement cost?
We price each job after finding the cause. Repair, parts or a full replacement all cost differently so the first step is a diagnosis.
Do you offer maintenance contracts?
Yes. Scheduled maintenance plans are part of what we do, set at the interval the system needs. The report from each visit recommends the next date.
What makes a kitchen extract fan rattle or whine?
Noise typically comes from grease build-up, bearings, belts or loose fixings. Rattles, whines and grinding point to different faults and we find the exact cause on site.
About our extract fan repair in Old Heath
Every fan job begins with finding the fault. A noisy fan might need cleaning, new bearings or a new belt; a dead fan can point to the motor or its controls. You hear what we have found before any work goes ahead. If you have a fan shaking on its mountings and a fan that whines, hums or grinds, we can put it right, from belts and pulleys, fan motors and fan housings onwards.
In a place like Old Heath, extract fans are often older units on a wall or roof. An older fan that fails may be better replaced than repaired, and we’ll explain the options.
A written report with pictures follows each visit, so you have a record of what was done and when. Where the work is a TR19® Grease clean, the certificate is issued through the BESCA Vent Hygiene Elite portal.
- Place
- Old Heath (CO2, CO1, CO4)
- Region
- Essex
- Paperwork
- Photo report after every visit
- Price
- A fixed price before any work starts
- Hours
- Nights, weekends or holidays to suit you
- Call
- 0345 646 2711
- Checked
- 30 October 2026
Places near Old Heath
Also in Old Heath
Fixed quotes for extract fan repair in Old Heath
You’ll get a fixed price before we start. It takes into account:
- How many systems or sites are involved
- Access, including roofs, risers and ceiling voids
- Whether it’s a one-off visit or part of a schedule
- What state the system is in
Putting the work off seldom saves money. Build-up, wear and faults tend to get worse, not better, which can make the next visit longer. If you are unsure, call 0345 646 2711 or email us for straight advice and a fixed quote.
Helping us quote
We can often survey from pictures. The most useful are:
- The postcode and the type of business
- Close-ups of filters, grilles, hatches or access panels
- When the site is open and when it’s quiet
- The roof, plant room or outside wall the system runs to
Quoting starts with a diagnosis, either from photos and details you send or from a site visit. After that, you get a fixed price for the work so you know the cost before we start.
Multi-site and managed buildings
Multi-site operators often want one contractor and one number. We cover South East England and London, so a run of sites can go into one programme and kept on a regular cycle.
We also work for facilities teams across offices, schools and healthcare in Old Heath and across Essex. Work can be phased by floor, building or site to keep disruption down.
How the job changes from site to site
Roof and wall-mounted fans
Many kitchen extract fans sit on a roof or an outside wall. Access affects how long a repair takes and we plan around it.
Direct-drive fans
Many kitchen extracts use direct-drive fans. When the motor fails, replacing the whole fan unit can make more sense than repairing it, and we will explain why.
Extract fans in Old Heath
Sea air reaches Old Heath, which sits within about 3 miles of the coast. Rust and grease together wear a fan out sooner, and coastal air speeds up the rust. The FSA’s food hygiene register shows about 51 cafés, restaurants and staff canteens and about 32 sandwich bars and takeaways within roughly a mile and a half of the centre of Old Heath. Every one of them that cooks under a canopy depends on its extract fan to keep cooking. Kitchens in Old Heath get their food hygiene inspections from Colchester council. Food premises are expected to have suitable and sufficient ventilation under food hygiene rules. A kitchen without a working fan has a problem to fix quickly.
School kitchens cannot easily serve lunch without extraction, so if you look after one at a school like Old Heath Community Primary School, fix a failing fan before term starts.
Old Heath is about 1 mile south of Greenstead, in Essex. Sites in Old Heath get the same service as everywhere we cover: a survey first, a fixed quote, work timed around your hours and a report with pictures. We cover 644 places across Essex, large and small. We also work in Chelmsford, about 21 miles from Old Heath.
Work in CO2, CO1 and CO4 follows the same survey, fixed quote and written report as everywhere else we cover. Extract fan repair is available to premises on Wick Road, Haven Road and D'arcy Road and the roads around them. Close by, we work in The Hythe (1 mile north), Berechurch (1 mile south-west), Rowhedge (1 mile south-east), Greenstead (1 mile north) and Wivenhoe Cross (2 miles east). We also work in nearby towns such as Clacton-on-Sea (11 miles south-east), Maldon (14 miles south-west), Witham (13 miles west), Harwich (15 miles east), Halstead (13 miles west) and Heybridge (13 miles south-west).
Around Old Heath
Around Old Heath, our work takes us to kitchens and buildings near The Bell pub, Thomas Lord Audley School and Language College and Donyland Lodge, among other places. Old Heath’s nearest station is Hythe station, roughly 1 mile north of the centre. Well-known places in the area include Essex County Hospital (1.9 miles north-west) and Grandad's Photography Museum (1.5 miles north-west). Green spaces nearby include Cockaynes Wood.
The process
Every visit runs to the same pattern: protect the area, make the system safe, carry out the extract fan repair, clear away and hand over the paperwork. On site, the work takes an hour or two to diagnose, then longer if parts or a new fan are needed. Getting to the system matters more than parking in a place like Old Heath, so let us know how to reach it.
- We take details of the symptoms and book a time that suits the kitchen.
- On site, the fan is safely isolated.
- We diagnose the fault, checking the controls as well as the fan.
- You get a fixed price for putting it right.
- The work is done and the fan is tested running.
Getting ready for the visit
- Tell us about access, such as roof hatches, plant rooms, ceilings or locked areas
- Clear the space around the work
- Make sure equipment near the work can be switched off and left to cool
Ask for a quote
Quotes are quick. Call or email with a few details and you will typically have a fixed price within one working day. Where a survey is needed, we arrange a time that suits the site.
Read more
Common problems we fix in Old Heath
Blocked filters and greasy ducts make the fan work harder. A motor that strains runs hot, trips out or eventually burns out.
If you notice any of these, it’s worth a diagnosis:
- An extract fan that has stopped working
- A squealing belt on start-up
- Weak extraction and a smoky kitchen
- Vibration spreading from the fan into the ducts
If you look after a church or hall kitchen near St Barnabas, or anywhere in Old Heath, test the extract fan before a big event rather than on the day.
Questions to ask before booking
- What paperwork you get at the end
- Their accreditations, such as BESCA Vent Hygiene Elite, CHAS or SafeContractor
- Whether the figure could change on the day
- How VAT is shown on the quote
When something else is needed
An honest diagnosis matters more to us than a booking, so here’s what this work can’t put right:
- An extract system that was undersized from the start
- A greasy canopy and duct that a fan repair won’t touch
- Gas interlock faults that a Gas Safe registered engineer must deal with
If in doubt, phone us on 0345 646 2711 or send us an email and we’ll say what we think.
What we work on in Old Heath
- Kitchen extract fans
- Roof and wall fans
- Bearings
- Belts and pulleys
- Fan housings
- Fan motors
In-house cleaning or a specialist?
Away from the kitchen, the in-house job is mainly checking: clear grilles, a log of filter changes and reporting anything odd. Cleaning inside ducts and units is specialist work.
Good housekeeping makes our visits easier, not unnecessary. Clean filters and tidy surfaces slow the build-up, but hidden parts of the system still need specialist attention.