Thurrock · Ductwork cleaning
Grays ductwork cleaning
Specialist ductwork cleaning for Grays: diagnosis first, then a fixed quote, the work and a report with pictures. Ask us for a fixed quote.
- Duct runs with no cleaning record
- Thick deposits at the bottom of a vertical duct
- Years of grease along the duct floor
Why it’s worth doing now in Grays
A fire in a greasy duct is hard to reach and hard to stop. The duct can carry it to rooms, floors or roof spaces well away from the kitchen, so cleaning the duct is as important as cleaning the hood. A small fault found now is a quick job; the same fault found later can close the site.
What you pay reflects the actual work. That is why we survey first, from pictures or on site, and the price is agreed before we start.
What you get with us
- Trading since 2009
- Every job surveyed first
- A fixed price before any work starts
- BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease
See what affects the cost or our accreditations and certificates.
Ductwork cleaning in Grays, done properly
Each extract duct we take on in Grays goes through the full routine: we test the grease first, remove thick deposits by hand and degrease what’s left. Readings are taken again afterwards and pictures go into your report. Typical jobs include readings above 200 microns from a grease thickness test and an insurer asking for TR19 evidence, across access panels, vertical risers and horizontal duct runs.
Most kitchens in a town like Grays cannot close for a day, so the work is done after service, overnight or on a closed day. By the next service, the kitchen is ready to cook in again.
It’s worth checking any contractor’s accreditations. Ours are BESCA Vent Hygiene Elite membership, cleaning to BESA TR19® Grease, plus CHAS, SafeContractor and ISO 9001, and we’re fully insured.
How it works
Your staff do not need to do much on the day. Someone lets us in at the agreed time and shows us where everything is, and we take it from there. Afterwards, the area is left tidy and the written report follows. The more we can see of the system beforehand, the smoother the visit to Grays will be.
- We map the duct route and check where the access panels are.
- We measure grease thickness at set points before cleaning.
- Through the access panels, thick grease is removed by hand first.
- Next the ducts and risers are degreased, using whatever suits the deposit.
- Readings and photos are repeated and any section we couldn’t reach is recorded.
Preparing for the visit
- Let us know when the site is closed or quiet
- Mention any sign-in, permit or induction we need
- Clear the space around the work
Ask for a quote
Photos are the quickest way to a quote: wide shots of the system, close-ups of anything that worries you and how we’d get to it. Add the site type and your opening hours, and we can price many jobs without a visit.
Related advice
In-house cleaning or a specialist?
Your own staff can handle the daily basics: wiping down canopy surfaces, cleaning filters and keeping a simple log. Inside the ducts, risers and fan is specialist work, which is where we come in.
Good housekeeping makes our visits easier, not unnecessary. Clean filters and tidy surfaces slow the build-up, but the parts you can’t see still need a specialist at the right interval.
Grease, kitchens and Grays
At about 3 miles from the coast, Grays is close enough for sea air to matter. Salt air speeds up corrosion of roof-level fans, discharge cowls and their fixings. According to Food Standards Agency records, there are about 13 pubs and bars in and around Grays, up to about a mile and a half out. A pub or hotel kitchen that cooks every day builds up grease in its extract like any other. It’s Thurrock council that sends environmental health officers to food businesses in Grays. The cleanliness of the kitchen and its equipment, extraction included, is part of what they check. Keeping each certificate and photo report on file helps show the extract is looked after.
Healthcare kitchens, like those at hospitals such as Thurrock Community Hospital (about 0.9 miles north), often cook for long hours, which puts them in BESA’s heavier-use bands. School kitchens, at schools like Quarry Hill Academy for example, are normally cleaned in the holidays so no lunches are lost. If you run a church or community hall kitchen, near St John the Evangelist or elsewhere in Grays, its extract still collects grease from every lunch and event.
Grays is about 5 miles north-east of Dartford, in Thurrock. Sites in Grays get the same service as everywhere we cover: diagnosis first, a fixed price, out-of-hours working where needed and a written report with pictures. Grays is one of 26 towns, villages and districts in Thurrock where we work for commercial clients. There’s also a page for Maidstone, about 17 miles away.
We cover every part of RM17, RM16, RM20 and RM18 for ductwork cleaning and the roads nearby. We cover sites on London Road, College Avenue and Cresthill Avenue and nearby roads. With the A126 and B149 close by, Grays is easy for our technicians to reach for ductwork cleaning. Other places close to Grays include Little Thurrock (1 mile north-east), Chafford Hundred (1 mile north-west), Orsett Heath (1 mile north-east), North Stifford (2 miles north-west) and Chadwell St Mary (2 miles east). Further out, we also cover Stanford-le-Hope (5 miles north-east), South Ockendon (3 miles north-west), Balstonia (5 miles north-east), Corringham (6 miles north-east), Aveley (4 miles west) and Purfleet-on-Thames (4 miles west).
What’s near Grays
Around Grays, our work takes us to kitchens and buildings near Thurrock and Basildon College, Grays Convent High School and The Traitors Gate pub. The closest station to Grays is Grays station, roughly 0.6 miles south-west. Other landmarks nearby include Stone Castle (3.6 miles south-west) and Thurrock Community Hospital (0.9 miles north). The countryside around Grays includes Chafford Gorges Nature Park and Sawyers Lake.
How we price ductwork cleaning
A fixed price needs a few facts first. We check:
- Parking and loading at the site
- The number of sites or systems
- Site rules, permits and inductions
- The condition we find in the survey
The cost depends on the size of the system, the condition it’s in and how easy it is to reach. You get a fixed price before any work starts, so there are no surprises.
Helping us quote
A few details help us quote accurately. With your enquiry, please include:
- The times we could work without disrupting the site
- Any symptoms, from odd noises to smells or leaks
- Close-ups of filters, grilles, hatches or access panels
- Any previous report or certificate
We don’t publish a price list, because every site is different. Instead, we look at your site first, from pictures or a survey, and then give you a fixed quote. To start, phone us on 0345 646 2711 or email us.
Places near Grays
What else we do in Grays
Between visits
Here’s the after-treatment advice, short and simple:
- Keep to the interval on the report
- Check readings when the menu changes
- Never cook with a filter missing
- Flag drips from the duct right away
After the clean, the same points are tested again, giving you before and after readings. Photos of each section go alongside them.
The less grease gets past the canopy, the cleaner the duct stays. Clean, properly seated filters are the duct’s best protection.
Grays questions
Which fire and rescue service is responsible for Grays?
Fire safety enforcement in Grays is handled by Essex County Fire and Rescue Service. If a fire safety officer visits a commercial kitchen, they may ask about the fire risk assessment and how the extract is kept clean.
Do you work overnight in Grays?
Yes, we can come after you close and finish before you open. That way a site in Grays doesn’t have to lose a day’s trading. Let us know the hours you’re closed and we will book within them.
Do you cover Grays?
Yes. Our area takes in London and the counties of South East England, Grays included.
Is a quote from photos possible?
Yes, if we can see what we need. Otherwise, we book a survey at a time that suits the site, and the quote follows that.
What do you need from me for a quote?
Where the site is, what it is and when it’s open, along with a few pictures and any previous report.
Can we book visits on a schedule?
Yes, of course. Send details of the systems and how they’re used, and we’ll suggest a schedule and quote for it.
Who has the legal duty for fire safety?
The law calls them the responsible person. That’s generally the employer or the person in control of the premises, and in shared buildings more than one person can have duties. If you’re not sure, check your lease and fire risk assessment.
Can one contract cover all our sites?
Yes. Send the list of sites and the work at each and you will get one fixed quote.
For landlords and multi-site operators
Under the Regulatory Reform (Fire Safety) Order 2005, the responsible person must assess and reduce fire risk, which may be the employer, owner, landlord, FM or managing agent. With shared responsibility, good records help everyone.
Managing agents often deal with us directly. Send the address, what’s needed and how access works, and we’ll send a fixed quote.
When it’s something else
An honest diagnosis matters more to us than a booking, so here’s what ductwork cleaning will not do:
- Ductwork that is corroded, split or holed (that needs a ductwork contractor)
- A duct that’s too small or badly routed for the kitchen (a design issue)
- A failed fan motor at the end of the duct (a fan repair job)
If in doubt, phone us on 0345 646 2711 or drop us a line and we will say what we think.
What the work covers
- Horizontal duct runs
- Multi-storey ducts
- Bends and junctions
- Attenuators
- Vertical risers
- Access panels