Essex · Extract fan cleaning
Loves Green extract fan cleaning
Extract fan cleaning in Loves Green from ventilation hygiene specialists trading since 2009. Evenings, overnight and weekends, plus a 24/7 emergency line.
- Hot, greasy smells near the fan
- A noisy fan that has got louder over time
- Vibration from an unbalanced impeller
Your questions about extract fan cleaning in Loves Green
Which council inspects kitchens in Loves Green?
Food hygiene inspections in Loves Green are carried out by Chelmsford council. It helps to keep the extract cleaning records with your food safety paperwork, so they’re ready if asked for.
Do you work at weekends in Loves Green?
Yes, out-of-hours work is a big part of what we do. It means the site in Loves Green keeps running as normal. Tell us your opening hours when you ask for a quote.
How often does the fan need cleaning?
The fan follows the full system’s interval at BESA’s minimum intervals for your cooking hours. Grease readings and the fan’s condition can show it needs more.
What makes a kitchen extract fan vibrate?
Build-up on the impeller is a frequent reason, since uneven grease makes it run out of balance. It can also be wear in the bearings or motor, which our report will flag.
Can you clean the fan on its own?
Yes, a fan can be cleaned on its own. That helps when the fan needs attention before the next full clean, but it does not replace a full TR19 clean.
Will we have to shut during the visit?
Not normally. We need the work area to ourselves while we are on site, so the visit goes in a quiet slot.
Is it safe to clean the fan while the kitchen is open?
We always isolate the fan first, so it can’t run during the clean. That means the extract is off, so we clean while the kitchen is closed.
Which accreditations do you hold?
Duct Doctor is a BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease. CHAS, SafeContractor and ISO 9001 are in place too, and we carry full insurance.
Extract fan cleaning for kitchens and businesses in Loves Green
Grease on a fan is not spread evenly. Heavier deposits on some blades throw the impeller off balance, leading to vibration, noise and strain on the motor and bearings. A thorough clean removes the cause. The work covers discharge points, centrifugal fans and in-line fans, and the jobs we see most are a fan coated in grease inside its housing and fat spreading onto the roof or wall by the fan.
Rural kitchens often have long, low duct runs through a roof space or along an outside wall, and those horizontal sections are where grease settles. Access, parking and timings are agreed before the day.
Duct Doctor has been trading since 2009, and we’re a BESCA Vent Hygiene Elite member, cleaning to BESA TR19® Grease. CHAS, SafeContractor and ISO 9001 are in place too, and we carry full insurance.
- Where
- Loves Green (CM1)
- Wider area
- Essex
- Paperwork
- Certificate plus before-and-after pictures
- Quotes
- A fixed quote up front
- Hours
- Out of hours as standard, 24/7 emergency line
- Phone
- 0345 646 2711
- Reviewed
- 30 October 2026
What a clean will not put right
Some problems need a different service or another trade:
- A failed motor or worn bearings (that needs a fan repair or replacement)
- A fan that’s too small for the system (a design question)
- An impeller that is bent or split
If in doubt, give us a ring on 0345 646 2711, or email photos and we’ll say what we think before you book.
What the work covers
- Discharge points
- In-line fans
- Axial fans
- Centrifugal fans
- Fan housings
- Roof-mounted fans
For landlords and multi-site operators
Landlords, managing agents and facilities managers book us, not only the businesses that use the systems. Where a system serves more than one tenant, such as a shared riser, it helps to agree who arranges the work, and we’re happy to quote for all of it.
Where a tenant occupies the premises but the landlord owns the building, it’s worth checking the lease for who maintains the systems. We’re happy to deal with either side, and the report can go to both.
Grease, kitchens and Loves Green
It’s Chelmsford council that sends environmental health officers to food businesses in Loves Green. Extraction counts as kitchen equipment, so its condition can come up on the day. Our report lists what was cleaned and when, which is useful to have ready. Loves Green sits within the area of Essex County Fire and Rescue Service. Fire and rescue authorities enforce the Fire Safety Order in most non-domestic premises, and in a kitchen that fire risk includes the grease in the extract.
Where a hall near St Paul's Church, or anywhere in Loves Green, hosts lunch clubs or events, its extract gathers grease just as a café’s does. Historic houses near Loves Green, such as Hylands about 2.8 miles east, are a reminder that older buildings with event kitchens can have long, awkward duct routes. If you look after a school kitchen, at a school such as Highwood Primary School or anywhere near Loves Green, the holidays are the usual time for a TR19® clean.
Loves Green is about 5 miles west of Chelmsford, in Essex. From the centre of Loves Green to the outskirts, we cover extract fan cleaning for every kind of premises, from a single unit to a large public building. Loves Green is one of 644 towns, villages and districts in Essex we cover for commercial clients.
Postcode districts we cover here for extract fan cleaning: CM1. That includes premises on Highwood Road, Pool's Lane and Sparrows Close and nearby roads. If your site is just outside Loves Green, we cover Edney Common (1 mile east), Radley Green (1 mile north-west), Newney Green (2 miles north-east), Norton Heath (3 miles west) and Roxwell (3 miles north). Further out, we also cover Chelmsford (5 miles east), Basildon (10 miles south), Braintree (14 miles north-east), Harlow (12 miles west), Brentwood (7 miles south-west) and Maldon (13 miles east).
What’s near Loves Green
In Loves Green, that means kitchens and buildings near Green Man Public House, among other places. The closest station to Loves Green is Ingatestone station, about 3 miles south. Nearby you’ll also find Chelmsford and Essex Hospital (3.8 miles east) and Willingale Doe (3.6 miles north-west).
How the job changes from site to site
Fan housings and motors
Inside the casing, grease is thrown onto the walls. We clean it along with the blades.
Kitchens with long cooking hours
A fan in a long-hours kitchen runs for most of the day, so grease and wear build up together. Regular cleans help it keep going.
Between visits
After the visit, a few habits help the work last:
- Notice when the fan starts to sound different
- File the fan’s report with your other records
- Never cook with a filter missing
- Leave a clear route to the fan
Once it’s clean, the fan is closed up and run to check it’s working smoothly. If anything seems wrong, from vibration to wear, we note it, so you can plan any repair.
The fan stays cleaner when less grease gets past the canopy. Keep the grease filters clean, fitted and in place, and replace any that are damaged.
Also near Loves Green
What else we do in Loves Green
What we do, step by step
Your trading hours come first. Most visits are booked for when the area is out of use, such as evenings, overnight, early mornings or weekends. When the team arrives, the work area is protected and the relevant equipment is switched off to cool, and the job takes a couple of hours per fan, depending on its size and the build-up. Pictures of the system and its access let us plan the work in Loves Green before we set off.
- Diagnosis first: we look for grease, noise and vibration.
- With the fan isolated, the housing is opened.
- The impeller is cleaned blade by blade so it runs balanced.
- We clean the casing, the outlet and around the motor.
- We run the fan and note its condition in the photo report.
Getting ready for the visit
- Let us know about parking and loading
- Make sure equipment near the work can be switched off and left to cool
- Make sure someone can let us in and lock up afterwards
Ask for a quote
Quotes are quick. Send a few details and photos, and we usually reply with a fixed quote within one working day. Where a survey is needed, we arrange a time that suits the site.
Related advice
What staff can safely do
Some jobs should never be done in-house: opening up ductwork, cleaning fans, drop testing fire dampers and measuring grease call for the right kit, training and safe access. That is our job.
Staff cleaning and specialist work are not the same thing. Wiping filters daily and washing them weekly keeps the visible parts in order, but they don’t reach the grease that builds up further in. Reaching it takes a specialist with the right equipment.
Why deal with it now?
A fan that fails mid-service can stop a kitchen cooking. Grease is often where fan trouble begins, so keeping it clean is part of keeping it running. If it does fail, our 24/7 emergency line is there. In a place like Loves Green, ductwork and fans are easy to forget until something goes wrong.
When the work has to happen, how we reach it and how big the site is can all change the price. We take each of them into account, and the price is fixed before any work starts.
Why book with us
- Accredited under CHAS and SafeContractor, with ISO 9001
- One contact for all your sites in London and the South East
- Evenings, overnight and weekends, plus 24/7 emergency callout
- Every visit written up, with pictures
Take a look at what affects the cost or how to check a contractor.